Professional Documents
Culture Documents
TDC Forgings
TDC Forgings
OGSP CUTTER JOB REF: 5392 PROJECT: OIL INDIA DULIAJAN CLIENT: OIL INDIA LIMITED
CS FORGINGS
1. Material Specification
3.1 Sizes / Type of Flange / Pressure Class / Quantity as per Material data
sheet & Purchase Order
3.2 Dimensions & Tolerances: as per B16.5
3.3 Finish & Appearance: as per section 15 of SA 961.
3.4 Flange Facing finish (RF): 125 -250 AARH as per section 6.4.5.3 of B16.5
3.5 Repair by welding – not permitted
4.1 Steel shall be fully killed and shall conform to fine austenitic grain size as
per SA20.
5. Chemical Composition
5.1 Shall be as per Table 1 of SA 105 & in addition shall comply the following
requirements
5.1.1 Carbon content shall not exceed 0.23%
5.1.2 Carbon equivalent (CE) (Heat Analysis) shall not exceed 0.43% when
calculated CE= C + Mn/6 + (Cr + Mo+V)/6 + (Ni+Cu)/15.
5.1.3 CE shall be reported in MTC
6. Heat Treatment
Flanges / forgings shall be supplied in Normalized condition(S2.1 of SA105)
OGSP CUTTER PROCESS SOLUTIONS INDIA PRIVATE LIMITED Exhibit: F-08-02
OGSP CUTTER JOB REF: 5392 PROJECT: OIL INDIA DULIAJAN CLIENT: OIL INDIA LIMITED
CS FORGINGS
7. Mechanical Properties
8. UT Requirement
8.1 Forging 50mm thick & above shall be UT examined as per SA 388 in
accordance with S20 & SA 788.
9.1 Flanges RF (Gasket face) shall be finished to 125 – 250 AARH as per section
6.4.5.3 of B16.5
9.2 Any imperfection in the flange gasket facing is not permitted / is not acceptable.
10.1 S2.1(SA 105) – HT shall be carried out as specified under section 6 above
10.2 S4.2 (SA 105)- determine carbon equivalent as specified under section 5.1.2
above
11. Inspection
11.1 Inspection as specified in the purchase order