Professional Documents
Culture Documents
Touch Switch
Touch Switch
ON
TOUCH SWITCH
SUBMITTED TO
DIPLOMA IN
BONAFIDE CERTIFICATE
EXAMINER -1 EXAMINER-2
ACKNOWLEDGMENT
An Endeavour of a long period can be successful only with the advice of many well-wishers. I
take this opportunity to express my deep gratitude and appreciation to all those who encouraged me for
successfully completion of the Project.
I wish to express our sincere gratitude to Dr. M. RAMA SUBBAMMA, M. Tech, Ph.D., M.I.E,
MISRD and MIEEE Principal of Global College of Engineering and Technology, Kadapa for his
consistent help and encouragement to complete the Project.
Our special thanks to Dr. S. Farooq Anwar, M.Tech., Ph.D., Professor and Head of the
Department, Department of E.C.E. during the progress of project, for his timely suggestion and help
inspires of her busy schedule.
Finally, I would like to express our sincere thanks to Faculty Members of E.C.E. Department,
Lab Technicians and Friends one and all who are helped us directly or indirectly in successful
completion of Project.
As a gesture of respect for our family members and for the support, I received from them.
SUBMITED BY
1. P. PEERAIAH (20360-EC-031)
2. B. VENUGOPAL REDDY (20360-EC-047)
3. POKURI VARALAKSHMI (20360-EC-030)
4. PALEM ASHAD BASHA (20360-EC-026)
5. BOLLU NITIN (20360-EC-005)
3
ABSTRACT
This project report entitles to “TOUCH SWITCH”. This work focuses on using
rain sensor, and it can be used in both everyday life and manufacturing.
A touch switches apparatus for detecting the presence of an object such as a
human
appendage, the apparatus having a switch and a local control circuit connected to the switch
and to a controlled device. The control circuit is preferably in integrated circuit form.
Electronic on/off switch for a load connected to an a-c supply network, including a
controlled semiconductor switch connected in a series circuit with the load, control circuit.
First of all, let us consider a few basics in building electronic circuits on a printed
circuit board. Smart Kit boards also come pre-drilled and with the outline of the
components and their identification printed on the component side to make construction
easier. The soldering iron that you use must be light and its power should not exceed the 25
Watts.
Make sure that you do not use more solder than it is necessary as you are running
the risk of short-circuiting adjacent tracks on the board, especially if they are very close
together. – After having finished your work cut off the excess of the component leads and
clean the board thoroughly with a suitable solvent to remove all flux residues that still
remain on it.