Professional Documents
Culture Documents
Appendix B LYNAS MY 000 INS DS 003 (Ball Control Valve)
Appendix B LYNAS MY 000 INS DS 003 (Ball Control Valve)
INSTRUMENT DATSHEET
BALL CONTROL VALVE
Rev. Prepared by: Date Reviewed by: Date Approved by: Date
A MAZ 1/9/2022
PROJECT: Lynas Advanced Materials Project
CLIENT: Lynas Malaysia Sdn Bhd
PROJECT NO.:
TITLE: Instrument Datasheet for DOCUMENT NO.: LYNAS-MY-000-INS-DS-003 SHEET: Rev
Ball Control Valves CLASS: 2 A
NOTES:-
2. All valves shall be provided with 30mm X 75mm 316SS tag plate, inscribed with tag number,
service and plant name engraved or embossed in 6mm high and 0.3mm deep bold characters.
The tag shall be mounted on or adjacent to the assosiated instrument and either fixed with
stainless steel screws or attached with stainless steel wire. Control valve accessories like I/P
transducer/positioner shall be tagged as TY/FY-XXXX, where XXXX shall be the same as
control valve tag number.
3. Sizing
a) Vendor shall verify (update datasheets as indicated including calculated and rated Cv) and be
responsible for sizing and selection of control valve and actuators, and submit all calculations
pertaining to/for purchased review during bidding and also as part of final document.
4. Control Valves shall meet design pressure and temperature rating as indicated in valve datasheet.
5. Input signal to the combined I/P transducer & positioner shall be 4-20mA.
6. The air filter regulator shall be suitable for the instrument air design pressure. Material of
construction for body, spring case and bowl shall be standard manufacturer.
7. All control valves accessories like positioner, I/P transducer, filter regulator, Etc shall be mounted
on the valve actuator.
8. Bolts, nuts, and gasket material shall be as per the respective body material piping classes.