Professional Documents
Culture Documents
NTB02 094
NTB02 094
SERVICE INFORMATION
If it is necessary to keep the crankshaft from rotating during engine service (such as
crankshaft pulley removal, etc.), use the new “Ring Gear Stopper” tool P/N J-45499.
• This tool applies ONLY to vehicles equipped with automatic transmission. To keep the
crankshaft from rotating on a manual transmission equipped vehicle, place the
transmission in gear and apply the parking brake.
• The new tool can be easily installed in the torque converter inspection opening on the
bell housing. Refer to the Service Procedure on page 2 for instructions.
• For additional information about this tool, refer to the Essential Tool Shipment Flyer,
page 3.
• J-45499 is an essential tool and was already sent to all Nissan dealers.
• Each dealer’s non-vehicle account will be billed $22.80 plus applicable taxes and freight
for this new tool.
• Additional tools can be ordered from Tech-Mate by calling 1-800-662-2001
TP020434
1/3
SERVICE PROCEDURE
1. Remove three bolts and remove the Torque Converter Inspection Cover (see Figure 1).
10mm
Hex bolt
(remove)
14mm
Hex bolt Torq Converter
Front Inspection Cover
(remove)
(remove)
Bell
Housing
Front
Bolt
(reuse) Flex plate
Bell housing
TP020436
Figure 2
2/3
2002 Nissan
EG-130-02-06
The following service tools have been classified essential by Nissan North America, Inc.
J-45499
Ring Gear Stopper
Application: Frontier (4 Cylinder A/T)
Note: This special service tool was developed to hold the crankshaft
stationary during on-vehicle engine service such as camshaft sprocket
or crankshaft pulley removal. Use of this tool reduces the risk of
camshaft damage when loosening the cam sprocket mounting bolt.
Be sure to disconnect the negative battery cable prior to installing the ring gear stopper to prevent starting
attempts. You may need to manually rotate the crankshaft slightly to fully engage the stopper in the ring gear
teeth. On M/T vehicles, the ring gear stopper is not required since the transmission may be placed in gear
and the parking brake set to hold the engine stationary.
J-38879-B
Lock Ring Tool
Application: Altima
Note: This special service tool was developed to remove and replace
the lock ring on the fuel pump assembly when service or replacement is
required. The universal design enables this tool to be used on several
different Nissan models.
These essential tools will be invoiced to your Nissan non-vehicle account at $61.32 (plus appropriate
taxes and freight) in accordance with your dealer agreement with Nissan North America, Inc.
Promotion # NI02-123
TP020437
3/3