Professional Documents
Culture Documents
8030 Series Wheel Tractors 8130 8230 8330 8430 8530 Replacement Parts Guide
8030 Series Wheel Tractors 8130 8230 8330 8430 8530 Replacement Parts Guide
OIL FILTER Initial oil and filter change at 100 hours, then
RE269061 3
2 8 7
after every 250 hours or as required, whichever
occurs first.
Replace after every 1500 hours. 5 7
The extended 50 percent service interval is
only allowed if using John Deere Plus-50 oil
with a John Deere filter. If diesel fuel with sulfur
ENGINE content is 0.2 - 0.5% used, then regular interval
of 250 hours between oil changes will reduced
FUEL TANK VENT FILTER to 150 hours.
RE52504 If all conditions are not met, change oil and
filter at 250 hours of operation.
4
Replace every 750 hours. (Interval may-
vary according to operating conditions.)
CAPACITIES (Approximate):
Transmission and Hydraulic System:
Fuel Tank:
Hy-Gard™
...............................................................................681 L (180 gal)
MFWD and 2WD......................................................150 L (40 gal)
Cooling System:
Independent Link Suspension..................................160 L (42 gal)
Cool-Gard™ II
................................................................................40 L (10.6 gal)
Mechanical Front Wheel Drive (MFWD) Axle:
Hy-Gard™
Crankcase (2WD or 1300 MFWD):
1300 Axle Differential Case....................................13.6 L (3.6 gal)
Plus-50™
1500 Axle Differential Case....................................18.7 L (4.9 gal)
8130-8230-8330.......................................................24 L (6.3 gal)
Wheel Hub................................................................3.4 L (0.9 gal)
8430.......................................................................25.5 L (6.7 gal)
Independent Link Suspension .................................4.0 L (1.0 gal)
6 RE582500
RE234166 - Rear window 7
8
12
16
11
HITCH AND SCV 19
14
15
13
10 20
9 16
HITCH MAINTENANCE
18 17
RADIATOR CAP
R207665 - Sway Block RH RE43593
21
R210605 - Sway Block Wear Plate RH 17
6
R207666 - Sway Block LH
R210604 - Sway Block Wear Plate LH WATER PUMP
RE334232 -Rockshaft position sensor RE530194
18
SCV
A/C COMPRESSOR
RE577560 - Breakaway coupler AH169875
R186598 - Snap Ring
RE186600 - Seal Kit 7 19
TORSIONAL DAMPER
10
RE586976