Professional Documents
Culture Documents
Materials
Materials
Materials
in
first-lms
Question 1
Complete
Flag question
Question text
Feedback
compression on spring,
Question 2
Complete
Flag question
Question text
Plasticity
Question 3
Complete
Flag question
Question text
Feedback
Question 4
Complete
Flag question
Question text
Feedback
Brittle
Question 5
Complete
Flag question
Question text
The ratio maximum BM in two identical simply supported beams under same loading
and but with different material is equal to
Feedback
Question 6
Complete
Flag question
Question text
A beam cross-section is used in two different orientations as shown below. The bending
moment applied to the beam in both cases is same. The maximum bending stresses
induced in case (A) and case (B) are
Feedback
σA = 2σB
Question 7
Complete
Flag question
Question text
Feedback
modulus of rigidity
Question 8
Complete
Flag question
Question text
Feedback
before fracture
Question 9
Complete
Flag question
Question text
Feedback
Shear deformation
Question 10
Complete
Flag question
Question text
Feedback
Question 11
Complete
Flag question
Question text
Feedback
Question 12
Complete
Flag question
Question text
The observations in measuring the width of a beam with Vernier calipers having least
count of 0.01 mm, are main scale reading = 9 mm, vernier coincidence = 42. The width
of beam is
Feedback
9.42 mm
Question 13
Complete
Flag question
Question text
Maximum shear developed in a circular solid shaft under pure torsion is 15 MPa. If the
diameter is halved, corresponding shear developed with same torque is:
Feedback
120 MPa
Question 14
Complete
Flag question
Question text
Feedback
Proof stress
Question 15
Complete
Flag question
Question text
In the compression test on spring experiment conducted in the laboratory, the applied
load is measured by
Feedback
Question 16
Complete
Mark 2.00 out of 2.00
Flag question
Question text
Feedback
Force method
Question 17
Complete
Flag question
Question text
Feedback
Strain energy
Question 18
Complete
Flag question
Question text
In the tension test of a mild steel bar the ultimate failure represents a:
Feedback
Question 19
Complete
Flag question
Question text
On a 20 mm diameter shaft, the twist at a section 200 mm from the fixed end is
recorded as 0.002 radians in a torsion test. The shear strain in the shaft is
Feedback
1x10^-4
Question 20
Complete
Flag question
Question text
What will the value of the Poisson’s ratio be, if Young’s modulus is equal to the bulk
modulus?
Feedback
0.334
Question 21
Complete
Flag question
Question text
The Young’s modulus of elasticity and Poisson’s ratio of a material are 210 GPa and
0.25 respectively. Then the bulk modulus of the material is
Feedback
140 GPa
Question 22
Complete
Flag question
Question text
The deflection at a point in a beam subjected to a concentrated load is δ. If the depth of beam
is doubled and the load is reduced to 50% of the earlier load, then deflection at the same point
will be
Feedback
Question 23
Complete
Flag question
Question text
A thin mild steel wire is loaded by adding loads in equal increments till it breaks. The
extensions noted with increasing loads will behave as:
Feedback