Professional Documents
Culture Documents
Ir Invenio R
Ir Invenio R
INVENIO R spectrometer
Table of Contents
1 Purpose of this document ............................................................... 2
2 Installation information.................................................................... 2
3 Intended use of spectrometer ......................................................... 2
4 Site requirements ............................................................................. 3
4.1 Space ................................................................................................................... 3
4.2 Environmental conditions ................................................................................. 3
4.3 Power supply ...................................................................................................... 4
4.4 Dry air .................................................................................................................. 4
4.5 Cooling water...................................................................................................... 4
4.6 Weight/Dimension .............................................................................................. 4
2 Installation information
Installation and initial operation of the spectrometer will be performed by qualified service
personnel of Bruker Optik GmbH. The operating company has to prepare the spectrometer
installation site in time, and provide the utilities required.
If the delivery of a data system and/or the installation of the operating system and spectroscopy
software are not part of the delivery content, the operating company also needs to provide a
data system that complies with the technical requirements, and incorporates the user rights
required.
If you have any further questions regarding the installation preparation procedures, contact
Bruker Service (service.bopt.us@bruker.com).
4 Site requirements
4.1 Space
Temperature variations in case of long- - not more than 1°C per hour
term measurements:
- not more than 2°C per day
1
When the spectrometer was stored outside the operating temperature range specified, the spectrometer must
have been acclimatized before you can switch it on.
For safety purposes make sure that interfaces of electric accessories connected to the
spectrometer comply with SELV (safety extra low voltage) circuit requirements. This is met if the
accessory design is based on the requirements outlined in EN 61010 or EN 60950.
Dry, oil-free and dust-free air (dew point below -40°C) or nitrogen gas
Recommendation: use of DIN purity class 1-1-1 (dryness – residual oil – particles)
Controllable gas flow, recommended gas flow rate: 200l/h, it must not exceed 500l/h
Air or gas-supply connection: hose with an outer diameter of 6mm. Ensure that the hose is rated
for the indicated operating pressure.
4.6 Weight/Dimension
Weight: approx. 65 kg (basic configuration) Note: The exact weight depends on the
configuration.
Dimension without touch panel: 68 x 76 x 32 cm (width x depth x height)
Dimension with touch panel: 68 x 76 x 50 cm (width x depth x height)
Height with opened sample compartment lid: 62 cm
5 Technical drawings