Professional Documents
Culture Documents
Railway Recruitment 2022
Railway Recruitment 2022
NOTIFICATION
Engagement of Apprentices under the Apprentices Act 1961, over Central
Railway.
1. Candidates should note and take cognizance of the fact that this is a
Centralized Notification for engagement of Act Apprentices under the
Apprentices Act 1961 for Central Railway Units and Railway Recruitment Cell,
Central Railway (RRC/CR) has been nominated as nodal agency for obtaining
ONLINE applications from candidates and preparation of their merit list.
Candidates can submit their applications ONLINE only on RRC’s website
www.rrccr.com
4. MODE OF SELECTION:
4.1 Selection will be on the basis of merit list prepared in respect of all the
candidates who apply against the notification. The merit list will be
prepared on the basis of percentage of marks in matriculation (with
minimum 50% aggregate marks) + ITI marks in the trade in which
Apprenticeship is to be done. The panel will be on the basis of simple
average of marks in the matriculation and ITI.
1
the trade applied / marks mentioned in the Provisional National Trade
Certificate issued by NCVT / SCVT, will only be reckoned.
NOTE-I: To avoid last minute rush, candidates are advised in their own
interest to submit ONLINE application much before the closing date,
to avoid possible inability/failure to log on to the website of RRC on
account of heavy load on the internet or website jam during last
days.
NOTE-II: RRC does not accept any responsibility for the candidates not being
able to submit their application within the last day on account of
aforesaid reasons or any other reason.
6. Candidates have to choose only one cluster. He/she can give preference for
the Units falling within the geographical jurisdiction of that cluster only. Cluster
and Units are as under :
Cluster Units
Mumbai Carriage & Wagon (Coaching) Wadi Bunder, Mumbai
Kalyan Diesel Shed
Kurla Diesel Shed
Sr.DEE(TRS) Kalyan
Sr.DEE(TRS) Kurla
Parel Workshop
Matunga Workshop
S&T Workshop, Byculla
2
Cluster Units
Bhusawal Carriage & Wagon Depot
Electric Loco Shed, Bhusawal
Electric Locomotive Workshop, Bhusawal
Manmad Workshop
TMW Nasik Road
Pune Carriage & Wagon Depot
Diesel Loco Shed
Nagpur Electric Loco Shed, Ajni
Carriage & Wagon Depot
Solapur Carriage & Wagon Depot
Kurduwadi Workshop
Note : Please go through the available training slots given below vis-à-vis your
ITI Trade thoroughly and select the Cluster and the Units accordingly. It should
not happen that you select a Cluster or unit where there is no training slot
requirement for your ITI Trade. In such a situation your application may
eventually become meaningless, as you would not be allowed to make any
changes after the final submission. Moreover, you are also not allowed to make
subsequently or multiple applications as in such an eventuality, all the
applications of yours shall be summarily rejected.
3
5 Mechanic 17 9 5 2 33 1 1 Mechanic 1 year
Diesel (Diesel)
TOTAL 26 13 8 3 50 1 0 0 0 1
MUMBAI CLUSTER
SR.DEE(TRS) KALYAN
Sr. ITI pass in Training
Break-up of training slot
No trade to be period
. Trades UR OBC SC ST TL OH VH HH MD Ex. eligible for
considerati
on
1 Fitter 31 17 9 5 62 1 1 2 Fitter 1 year
SR.DEE(TRS) KURLA
1 Fitter 46 24 13 7 90 1 1 1 1 3 Fitter 1 year
TOTAL 97 52 29 14 192 2 2 2 2 6
4
PAREL WORKSHOP
1 Fitter 25 14 8 4 51 1 1 0 2 Fitter 1 year
MUMBAI CLUSTER
MATUNGA WORKSHOP
Sr. ITI pass in Training
Break-up of training slot
No trade to be period
. Trades UR OBC SC ST TL OH VH HH MD Ex. eligible for
consideration
1. Machinist 12 7 2 3 24 1 1 Machinist 1 year
5
2 Turner 3 2 1 6 Turner 1 year
BHUSAWAL CLUSTER
CARRIAGE & WAGON DEPOT
Sr. ITI pass in Training
Break-up of training slot
No. trade to be period
Trades UR OBC SC ST TL OH VH HH MD Ex. eligible for
consideration
1 Fitter 54 29 16 8 107 3 1 3 Fitter 1 year
2 Welder 7 2 2 1 12 Welder 1 year
BHUSAWAL CLUSTER
ELECTRIC LOCO SHED
Sr. ITI pass in Training
Break-up of training slot
No. trade to be period
Trades UR OBC SC ST TL OH VH HH MD Ex. eligible for
consideration
1 Fitter 19 10 6 3 38 1 1 1 Fitter 1 year
TOTAL 40 21 13 6 80 2 0 0 2 2
6
4 Programming 2 2 Computer 1 year
& Systems Operator &
Administration Programming
Assistant Assistant
TOTAL 62 31 17 8 118 4 0 0 0 4
MANMAD WORKSHOP
1 Fitter 14 7 4 2 27 1 1 Fitter 1 year
TOTAL 17 9 3 2 31 1 0 0 0 1
NAGPUR CLUSTER
ELECTRIC LOCO SHED, AJNI
Sr. ITI pass in Training
Break-up of training slot
No. trade to be period
Trades UR OBC SC ST TL OH VH HH MD Ex. eligible for
consideration
1 Electrician 17 9 5 2 33 1 0 0 1 Electrician 1 year
2 Electronics 8 4 2 1 15 Electronics 1 year
Mechanic Mechanic
TOTAL 25 13 7 3 48 1 0 0 0 1
TOTAL 34 17 10 4 66 1 0 1 0 2
SOLAPUR CLUSTER
CARRIAGE & WAGON DEPOT
Sr. ITI pass in Training
Break-up of training slot
No. trade to be period
Trades UR OBC SC ST TL OH VH HH MD Ex. eligible for
consideration
1 Fitter 20 11 6 3 40 2 2 Fitter 1 year
2 Carpenter 2 2 Carpenter 1 year
3 Machinist 2 2 4 Machinist 1 year
4 Welder 4 1 1 1 7 Welder 1 year
KURDUWADI WORKSHOP
1 Fitter 4 2 1 7 Fitter 1 year
2 Machinist 3 1 1 5 Machinist 1 year
3 Welder 2 1 1 4 Welder 1 year
8
NB : PwBD means Person with Disability and Ex. means Ex-Servicemen. Seats
of PwBD and Ex-Servicemen in the above tables are not separate, but included
in the total number of seats.
The number of training slots shown in this Notification are provisional and the
same are liable to increase or decrease depending upon the actual needs of
the administration at the time of finalization of selection.
8. ELIGIBILITY CONDITIONS
8.1 The candidates should have completed 15 years of age and should not
have completed 24 years of age as on 15-12-2022.
8.2 Upper age limit is relaxable by 05 years in case of SC/ST candidates, 3
years in case of OBC candidates.
8.3 For Persons with Disability, upper age limit is relaxed by 10 years.
9. EX-SERVICEMEN
11.2 Fee payment will have to be made online through payment gateway as
part of online application process as under:
- Once the online application is complete in all respects at RRC/CR’s
website www.rrccr.com, candidates will be directed to payment
gateway of SBI’s website to make payment.
- Once the payment is successfully done, candidates will be
redirected to RRC/CR’s website to complete the application process
and download the application form.
- In case the candidates tried to make payment before and come
across some issues like loss of internet connection due to which the
fee amount has been deducted from their Account/Debit/Credit
Card but still unable to download the application, please click on
10
“Verify Payment” button to reconfirm the same from the Payment
gateway.
11.3 After ensuring the correctness of the particulars of the application form
candidates are required to pay fees through the payment gateway
integrated with the online application. No change/edit will be allowed
thereafter.
11.4 The payment can be made by using debit card / credit card / Internet
Banking / SBI Challan etc. by providing information as asked on the
screen. Transaction charges for online payment, if any, will be borne by
the candidates.
12.1 Only Loco motor or Cerebral palsy (OH) who suffers from not less than
40% of relevant disability and Hearing Handicapped (HH) having 60
decibels or more in the better ear in the conversational range of
frequency are eligible to apply.
a) Blindness
“Blindness” refers to a condition where a person suffers from any of the
following condition, namely:
i) Total absence of sight, or
ii) Visual acuity not exceeding 6/60 or 20/2000 (snellen) in the better eye
with correcting lens;
iii) Limitation of the field of vision subtending an angle of 20 degrees or
worse.
12.4 Person with Disability (PwBD) who wants to avail the benefit of
reservation must produce a disability certificate issued by a competent
authority (i.e. Medical Board duly constituted by the Central or State
Government including one specialist in the particular field for assessing
disability). Disability certificate should be strictly as per the annexure-III
/ IV / V / VI attached.
Applicants from these states can enter in the online application form, their
voter ID number, valid passport number, driving license number or any
other valid Government identity card at the time of online application.
Candidates are also required to upload their signature (size 3.5 cm x 3.5
cm, JPG/JPEG format, 100 DPI, size of the file should be between 20
13
kb - 30kb).
16.3 Consolidated mark sheet for all semesters of the trade in which applied
/ Provisional National Trade Certificate indicating marks.
14
i. Technician (vocational) 7000 per month
apprentice or Vocational
Certificate holder or
Sandwich Course
(Students from Diploma
Institutions) `
19.4 It is not obligatory on the part of employer to offer any employment to the
passed out trade apprentice on completion of the period of Apprenticeship
Training in his establishment nor shall it be obligatory on the part of the
Apprentice to accept an employment under the employer.
19.5 In case the selected candidate is minor then, his/her guardian has to
enter into a Contract of Apprenticeship with the employer.
21.1 For any problems in the Online submission and printing of Application,
email at act.apprentice@rrccr.com
22.5 Before applying, the candidates should ensure that he/she fulfils the
eligibility and other criteria. If erroneously engaged, such candidates
shall be summarily dismissed without notice at any stage.
22.7 Before applying, the candidates should ensure that he/she fulfils the
eligibility and other criteria. If erroneously engaged, such candidates
shall be summarily dismissed without notice at any stage.
22.9 The Railway administration will not be responsible for any printing error.
16
22.10 No daily allowance / conveyance allowance or travelling allowance will
be paid to the candidates called for document verification.
Chairman/RRC
Central Railway
17
Annexure ‘I’
18
Annexure ‘II’
District Magistrate/
Dy.
Commissioner
Etc. (With seal
of office)
Place ……………………
Date ……………………
b. Where the certificates are issued by Gazetted Officers of the Union Government or State Governments,
they should be in the same form but countersigned by the District Magistrate or Dy. Commissioner
(Certificate issued by Gazetted Officers and attested by District Magistrate/Deputy Commissioner are not
sufficient)
c. The OBC certificate from the authorities only will be accepted:-
19
Annexure-III
Form-II
Disability Certificate
(In cases of amputation or complete permanent paralysis of limbs
and in cases of blindness)
(See rule 4)
(NAME AND ADDRESS OF THE MEDICAL AUTHORITY
ISSUING THE CERTIFICATE)
Recent PP size attested
photograph (showing
face only) on the
person with disability
Name and seal of Member Name and seal of Member Name and seal of Member
Chairperson
Signature and Seal of Authorized Signatory of
tified Medical Authority)
Signature/Thumb impression of the
person
in whose favour disability certificate
is issued
20
Annexure-IV
Form-III
Disability Certificate
(In cases of multiple disabilities)
(NAME AND ADDRESS OF THE MEDICAL AUTHORITY ISSUING THE
CERTIFICATE) (See rule 4)
(B) In the light of the above, his/her over all permanent physical impairment as per
guidelines (to be specified), is as follows:-
In figures:-_______________ percent.
In words:-_________________________________________ percent.
21
@ e.g. Left/Right/both arms/legs
Name and seal of Member Name and seal of Member Name and seal of Member
Chairperson
Signature/Thumb
impression of the
person in whose favour
disability certificate is
issued
22
Annexure-V
Form-IV
Disability Certificate
(In cases other than those mentioned in Forms-II and III)
(NAME AND ADDRESS OF THE MEDICAL AUTHORITY ISSUING THE
CERTIFICATE)
(See rule 4)
Recent PP
size Attested
photograph
(showing face
only) on the
person with
disability
23
@ e.g. Left/Right/both arms/legs
# e.g. Single eye/both
eyes. $ e.g.:
Left/Right/both ears.
4. The applicant has submitted following document as proof of residence
Name and seal of Member Name and seal of Member Name and seal of Member
Signature/Thum
b impression of
the person in
whose favour
disability
certificate is
issued
Note: In case this certificate is issued by a medical authority who is not a government
servant, it shall be valid only if countersigned by the Chief Medical Officer of the District.
Note: The principal rules were published in the Gazette of India vide
st
notification number S.O.908 (E) dated the 31 December, 1996.
24
Annexure-VI
NAME & ADDRESS OF THE INSTITUTE /HOSPITAL
DISABILITY CERTIFICATE
Certificate No…………………………………..
1. This is certified that Smt./Shri Kum*………………………………………………………………
son/daughter of Shri……………………………… age…………..sex Male/Female having
identification marks as below is suffering from permanent disability of following category:
Paste here your
Recent colour
A. Locomotor or cerebral palsy: Photograph showing
the disability(The
(i)BL-Both legs affected but not arms.
photograph should
(ii)BA-Both arms affected: (a)Impaired reach be attested by the
(b)Weakness of grip Chairperson of the
Medical Board)
(iii)OL-One leg affected (right or left) (a)Impaired reach
(b)Weakness of grip
(c)Ataxic
(iv)OA-One arm affected (right or left) (a)Impaired reach
(b)Weakness of grip Signature of candidate
(c)Ataxic in the above box below
the photograph
(v)BH-Stiff back and hips(cannot sit of stoop)
(vi)MW-Muscular weakness and limited physical endurance.
Note: (1) According to the Persons with Disabilities (Equal Opportunities, Protection of Right and Full
Participation) Rules, 1966 notified on 31.12.1996 by the Central Government in exercise of the powers
conferred by sub-Section (1) and (2) of section 73 of the Persons with disabilities (Equal Opportunities,
Protection of Rights and Full Participation) Act, 1995 (1 of 1996), authorities to give disability Certificate will
be a Medical Board duly constituted by the Central or the State Government. The State Government may
constitute a Medical Board consisting of at least three members out of whom at least one shall be a
specialist in the particular field for assessing the locomotor/hearing and speech/Visual disability. (ii) The
certificate would be valid for a period of 5 years of those whose disability is temporary. For those who
acquired permanent disability, the validity can be shown as ‘permanent.
25
Annexure-VII
Category : ………………………………………………………
Photo to be attested by
Date of Birth / Age : ……………………………………………………… Medical Officer
2. ……………………………………………………..
Observations of
S.No. Standard of physical fitness
Medical Officer
1. A candidate should be free evidence of any contagious or infectious disease. He should not
be suffering from any disease which is likely to be aggravated by service or is likely to
render him unfit for service or endanger the health of the public. He should also be free
from evidence of tuberculosis in any form, active or healed.
2. Height, Weight And Chest
Candidates should satisfy the following minimum standards, namely:-
HEIGHT: 137 centimeters; Weight:25.4 Kilogram; Chest expansion should not be less than
3.8 centimeters irrespective of size of chest:
Provide that where a candidate does not satisfy the said minimum standards but is certified
in writing by a Medical Officer not below the rank of an Assistant Surgeon (Gazetted), to be
physically fit for being engaged as an apprentice in a particular trade under the Apprentices
Act,1961, he may be engaged as an apprentice in that trade.
3. EYES
There should be no evidence of any morbid condition of either eye of the lids of either eye
which may be liable to risk of aggravation of recurrence.
Standard of Vision
(A) Visual acuity: *Candidates having vision in one eye shall eligible to undergo
apprenticeship training except in the following seventeen trades, namely :-
(1) Electrician Aircraft (2) Watch and Clock Mechanic
(3) Driver cum Fitter (4) Surveyor
(5) Process Cameraman (6) Sirdar
(7) Rigger(Engg. & Chem. Industry) (8) Shortfirer/Blaster (Mines)
(9) Mate (Mines) (10) Mech. Radio & Radar Aircraft
(11) Ceramic Moduler (12) Ceramic Caster
(13) Ceramic Kiln Operator (14) Ceramic Press Operator
(15) Ceramic Modeller (16) Ceramic Decorator
(17) Optical worker
(b) Colour vision: Not required
4. EARS
Hearing must be good in both ears and there should be no sign of suppurative disease. No
hearing aid shall be permitted.
5. SKIN
There should be no evidence of acute or chronic skin disease or chronic ulceration.
6. SPEECH
Speech should preferably be without impediment.
26
S.No. Standard of physical fitness Observations of
Medical Officer
7. ALIMENTARY SYSTEM
1. Candidates should have sufficient number of natural teeth (in healthy state) for
mastication.
2. Spleen should not be palpably enlarged and there should be no evidence of tenderness in
the splenic area.
3. Liver should not be palpable or tender.
4. There should be no oral sepsis.
5. There should be no sugar in the urine.
6. Candidates should not be suffering from haemorrhoids, fissures in and testis anal hernia
or bubonocele or ischio-rectal abscess or hydrocele.
8. CARDIO VASCULAR SYSTEM
1. Blood pressure should not exceed 85 diastolic and 140 systolic. 2. Candidates with low
blood pressure (i.e. systolic below 100) should be rejected. 3. There should be no sign of
any cardiovascular disease.
9. RESPIRATORY SYSTEM
Candidates should be free from all diseases of respiratory system. There should be no
deformity of chest which may cause impediment to breathing.
10. GENITO URINARY SYSTEM
There should be no evidence of genito urinary disease or any abnormality.
11. SKELETAL SYSTEM
1. The function of all limbs should be within normal limits.
2. There should be no evidence of serious deformity of the spinal column or of the
extremities.
12. NERVOUS SYSTEM
There should be no evidence of any disease of nervous system or of any mental disease.
13. GLANDULAR SYSTEM
There should be no evidence of tuberculosis or other disease of the glandular system
including the endocrine glands.
Above medical fitness certificate should be signed by Government authorized Doctor (Gaz), not below
the rank of Assistant Surgeon of Central / State Hospital
Registration No.
Designation
27