Download as pdf or txt
Download as pdf or txt
You are on page 1of 11

Dr.

Venkata Ramana Naik N


EC: 1151240,
Assistant Professor Grade-1,
Electrical Engineering Department,
National Institute of Technology Rourkela-769008.
Email: iitrramana@gmail.com ,
nenavathv@nitrkl.ac.in
Mobile: (+91) 876 398 3981
Office: (+91) 661 246 2406

Area(s) of Interest: Various PWM techniques and Multi-level Inverters / Converters


for reduction of current ripples, Speed Control Strategies for Induction Motor Drives,
PV fed motor drives for electric vehicle/grid connected /battery management
applications, EV Charging applications, Dual Active Bridge converters, Micro Grid and
applications of Fuzzy/ Neural/ Neuro-fuzzy control.

Summary of Experimental, Teaching and Research Work Experience:

 Research experience in the area of Power Electronics and Electric Drives,


DSP/dSPACE-DSP controller, Intelligent Controllers, and Digital Controllers.
 Hands-on experience for various power level converters, PV applications, Field
Oriented Control (FOC), and Direct Torque Control (DTC) of variable frequency
drives (VFDs). design up to a three-phase five-level diode clamped inverter
0.65kV/25A from base level including soldering and PCB design for MOSFET driver,
RCD snubber circuits, Dead band circuits etc,.
 Expertise in m-file programming, MATLAB/Simulink, PSIM, and DSPACE/DSPs/
Micro-controllers.
 Experience in design of power circuit topology, analog and digital circuit design,
dSPACE based control systems, the gate driving circuits and its protections, etc,.
 Eleven years Research experience since 2015.
 Approximately seven years teaching experience including one-year pre-PhD
experience.

EDUCATION BACKGROUND

Educational Qualifications Year Institute/University


Ph.D. in Indian Institute of Technology
Electrical Engineering 2016 Roorkee, UK
M. Tech in Jawaharlal Nehru Technological
Power Electronics 2009 University Anantapur, AP
B. Tech in
Electrical and Electronics Sri Krishnadevaraya University
Engineering 2006 Anantapur, AP
Intermediate in
M.P.C 2002 Govt. Junior College, Atmakur, AP
Sri Padmavathi High School,
Tenth Class 2000 Atmakur, AP
RESEARCH PUBLICATIONS
SCI International Journals:
1. N. Venkataramana Naik, and S. P. Singh, “A Novel Interval Type-2 Fuzzy Based Direct
Torque Control of Induction Motor Drive Using Five-level Diode-clamped Inverter,”
IEEE Transactions on Industrial Electronics, vol. 68, no. 1, pp. 149-159, Jan.
2021. (Impact Factor =8.236)
2. N. Venkataramana Naik, S. P. Singh and A. K. Panda, “An Interval Type-2 Fuzzy Based
DTC of IMD Using Hybrid Duty Ratio Control,” IEEE Transactions on Power
Electronics, vol. 35, no. 8, pp. 8443-8451, Aug. 2020. (Impact Factor =6.153)
3. A. Narendra, N. Venkataramana Naik, A. K. Panda, and Nishit Tiwary, “A
Comprehensive Review of PV-Driven Electrical Motors,” Solar Energy, Elsevier, vol.
195, pp. 278-303, Jan. 2020. (Impact Factor = 5.742)
4. N. Venkataramana Naik, Aurobinda Panda, and S. P. Singh, "A Three-Level Fuzzy-2
DTC of Induction Motor Drive Using SVPWM," IEEE Transactions on Industrial
Electronics, vol. 63, no. 3, pp. 1467-1479, Mar. 2016. (Impact Factor =8.236; No.
of Citations=60)
5. N. Venkataramana Naik and S. P. Singh, "A Comparative Analytical Performance of
Fuzzy-2 DTC and PIDTC of Induction Motor Using DSPACE DS-1104," IEEE
Transactions on Industrial Electronics, vol.62, no.12, pp.7350-7359, Dec. 2015.
(Impact Factor =8.236; No. of Citations=27)
6. N. Venkataramana Naik, Jose Thankachan, and S. P. Singh, “A Neuro-Fuzzy Direct
Torque Control Using Bus-Clamped Space Vector Modulation,” IETE Technical
Review, pp. 205-217, vol. 33, iss. 2, Mar. 2016. (Impact Factor =2.2; No. of
Citations=14).
7. N. Venkataramana Naik and S. P. Singh, "Improved Torque and Flux performance of
Type-2 Fuzzy Based DTC Induction Motor Using Space Vector Pulse-width Modulation,"
Electric Power Components and Systems, vol. 42, pp. 658-669, Mar. 2014. (Impact
Factor =1.398; No. of Citations=26)
8. N. Tiwary, N. Venkataramana Naik, A. K. Panda, Rajesh Kumar Lenka and A.
Narendra, “Sliding Mode and Current Observer Based Direct Power Control of Dual
Active Bridge Converter with Constant Power Load,” International Transactions on
Electrical Energy Systems (ITEES), Wiley, vol. 31, iss. 5, pp. 1-17, May 2021, DOI:
10.1002/2050-7038.12879 (Impact Factor =2.86).
9. A. Narendra, N. Venkataramana Naik, N. Tiwary and A. K. Panda, “An Improved
Performance of PV Fed IVC Induction Motor Drive Using Clamping Sequence Duty
Ratio Control,” International Transactions on Electrical Energy Systems (ITEES),
Wiley, Accepted in 2nd Aug. 2021, DOI:10.1002/2050-7038.13064 (Impact Factor
=2.86).
10. A. Narendra, N. Venkataramana Naik, A. K. Panda, and Nishit Tiwary, “SPV fed FVSI
based Induction Motor Drive for Water Pumping Applications,” TEC-00902-2021, IEEE
Transactions on Energy Conversion, Under Review.
11.N. Tiwary, N. Venkataramana Naik, A. K. Panda, Rajesh Kumar Lenka and A.
Narendra, “Super Twisting Sliding Mode Control of Dual Active Bridge DC-DC
Converter,” IEEE Transactions on Industrial Applications, 2021-IACC-0429, Under
Review.
12.N. Tiwary, N. Venkataramana Naik, A. K. Panda, and A. Narendra, “A Simple Sliding
Mode Based Direct Power Control of Isolated DC-DC DAB Converter for Improved
Voltage Regulation,” IETE Technical Review, Under Review.
BOOKS/BOOK-CHAPTERS PUBLISHED/ACCEPTED
1. Nishit Tiwary, Venkata Ramana Naik N, Anup Kumar Panda, Rajesh Kumar Lenka, and
Ankireddy Narendra, proposal for book chapter-13 entitle “Overview of control
strategies and design of isolated bidirectional dual active bridge converter for renewable
energy systems,” for the book titled on “DC-DC Converters for Future Renewable Energy
Systems,” e-Book ISBN:978-981-16-4388-0, DOI: 10.1007/978-981-16-4388-0,
Springer series, In Press.
2. Rajesh Kumar Lenka, Nishit Tiwary, Venkata Ramana Naik N, Anup Kumar Panda, and
A Narendra, proposal for book chapter-1 entitled “Multifunctional PV Integrated
Bidirectional Off-Board EV Battery Charger Targeting Smart Cities” for the book title on
“Technological Challenges and Advances in Wind and Solar Energy Applications” CRC
Press, Taylor & Francis Group, Accepted.
3. Nishit Tiwary, Venkata Ramana Naik N, Anup Kumar Panda, and A Narendra, proposal
for book chapter entitled “Isolated Bidirectional Dual Active Bridge (DAB) Converter for
Photovoltaic System- An Overview” for the book title on “Technological Challenges and
Advances in Wind and Solar Energy Applications,” CRC Press, Taylor & Francis Group,
Accepted.
4. Venkata Ramana Naik N and S. P. Singh, “Multi-Level Inverter Fed Induction Motor
Drive” Academic Publishing, Aug. 2017. (ISBN: 978-620-2-00652-1).
5. Ankireddy Narendra, Nishit Tiwary, Venkata Ramana Naik N, and Anup Kumar Panda,
proposal for book chapter 04 entitled of “Multilevel Inverter Topologies and Their
Applications", to be evaluated in Power Electronics for Next-Generation Drives and
Energy Systems (PENGDESs-2022), Volume 1, IET (Institution of Engineering and
Technology), Proposal in evaluation process for full chapter submission.
6. Ankireddy Narendra, Nishit Tiwary, Venkata Ramana Naik N, and Anup Kumar Panda,
a proposal chapter 05 titled "Design of Power Electronic Devices in the domain of
Energy Storage," to be evaluated in ''Emerging Trends in Energy Storage Systems and
Industrial applications (ETESSIA-2021),'' Elsevier, Proposal in evaluation process for
full chapter submission.

International/National Conferences:
1. Prerana Mohapatra, Venkata Ramana Naik N, Anup Kumar Panda and Nishit Tiwary,
“Normalized Gaussian Kernel LMS controlled Grid interactive PV based EV Charging
Station,” International conference on “Power Electronics, Smart Grid and Renewable
Energy (PESGRE 2022), Submitted.
2. Prerana Mohapatra, Venkata Ramana Naik N, Anup Kumar Panda and Nishit Tiwary,
“Kernel Based Affine Projection Algorithm for three-phase Grid connected Solar PV
System,”10th National Power Electronics Conference (NPEC-2021), Submitted.
3. N. Tiwary, N. N. Venkataramana, A. K. Panda, A. Narendra, and Rajesh Kumar Lenka,
“Fuzzy Logic Based Direct Power Control of Dual Active Bridge Converter,” 2020 IEEE
International Conference on Power Electronics and Energy (ICPEE), Bhubaneswar.
4. Rajesh Kumar Lenka, A. K. Panda, Ashish Ranjan Dash, N. Venkata Ramana Naik and
N. Tiwary, “Reactive Power Compensation using Vehicle-to-Grid enabled Bidirectional
Off-Board EV Battery Charger,” 2020 IEEE International Conference on Power
Electronics and Energy (ICPEE), Bhubaneswar.
5. Nishit Tiwary, Venkata Ramana Naik N, Anup Kumar Panda, Rajesh Kumar Lenka and
Ankireddy Narendra, “Super Twisting Sliding Mode Control of Dual Active Bridge DC-DC
Converter,” Ninth IEEE International Conference on PEDES-2020, MNIT Jaipur,
2020.
6. Venkata Ramana Naik N “An Interval Type-2 Fuzzy Based DTC of IMD Using Hybrid
Duty Ratio Control,” 13th IEEE International Conference on Power Electronics
and Drive Systems (PEDS)-2019, Toulouse, France, pp.1-3, Jul. 2019.
7. Venkata Ramana Naik N. “A Real-time Enactment of Fuzzy Based Direct Torque
Control of Induction Motor Drive with DS-1104,” 10th International Conference on
Computing, Communications and Networking Technologies (ICCCNT-2019), IIT
Kanpur, pp.1-5, Jul. 2019.
8. A Narendra, Venkata Ramana Naik N, Anup Kumar Panda, and Nishit Tiwary, “A
Real-Time Implementation of PV Driven DC Motor along with Wireless Control”. 10th
International Conference on Computing, Communications and Networking
Technologies (ICCCNT-2019), IIT Kanpur, pp.1-4, July 2019.
9. N. Tiwary, Venkata Ramana Naik N, A. K. Panda and A. Narendra, “Direct Power
Control of Dual Active Bridge Bidirectional DC-DC Converter,” International
Conference on Power Electronics, Control and Automation (ICPECA), Jamia
Millia Islamia University, New Delhi, India, pp. 1-4, Nov. 2019
10. A. Narendra, N. Venkataramana Naik, A. K. Panda, and N. Tiwary, "Modelling and
Analysis of Grid-tied Solar PV System," 2019 International Conference on Power
Electronics, Control and Automation (ICPECA), Jamia Millia Islamia University,
New Delhi, India, pp. 1-5, Nov. 2019.
11. A Narendra and Venkata Ramana Naik N, “An Experimental Validation of single-
phase AC power Generation from PV using H-bridge Inverter,” IEEE International
Conference on PEDES-2018, IIT Madras, 2018, pp. 1-5. (No. of Citations=1)
12. A Narendra, Venkata Ramana Naik N and Nishit Tiwary, “PV fed Separately
Excited DC Motor with a Closed Loop Speed Control,” IEEE International
Conference on PIICON-2018, NIT Kurukshetra, 2018, pp. 1-5. (No. of
Citations=2)
13. Venkata Ramana Naik N and S. P. Singh, "A two-level fuzzy-based DTC using
PLLC to improve the induction motor performance," IEEE International Conference
on PEDES-2016, Trivandrum, 2016, pp. 1-5. (No. of Citations=3)
14. Venkataramana Naik N, S. P. Singh, and G. Durgasukumar, "An improved
performance of F2DTC induction motor using five-level SVM," IEEE International
Conference on PEDES-2016, Trivandrum, 2016, pp. 11-16. (No. of Citations=2)
15. N. Venkataramana Naik and S. P. Singh, "Improved Dynamic Performance of
Type-2 Fuzzy Based DTC Induction Motor Using SVPWM," International IEEE Conf.
Proc, PEDES-2012, IISc Banglore, pp. 1-5, Dec. 2012. (No. of Citations=11)
16. N. Venkataramana Naik and S. P. Singh, "Improved Dynamic Performance of
Direct Torque Control at low speed over a scalar control," International IEEE Conf
Proc, INDICON-2013, IIT Bombay, pp. 1-5, Dec. 2013. (No. of Citations=12)
17. N. Venkataramana Naik and S. P. Singh, “A Comparative Study of V/f Controlled
IM Using Two and Three-Level Bus Clamped SVM," International IEEE Conf, IICPE -
2014, NIT Kurukshetra, pp. 1-6, Dec. 2014. (No. of Citations=2)
18. N. Venkataramana Naik and S. P. Singh, “A NF Based Direct Torque Control of
Induction Motor Drive Using BCSVM," International IEEE Conf, IICPE -2014, NIT
Kurukshetra, pp. 10-11, Dec. 2014. (No. of Citations=2)
19. N. Venkataramana Naik and S. P. Singh, "Improved Dynamic Performance of
Fuzzy Based DTC Induction Motor Using Bus-Clamped SVM," International IEEE
Conf. Proc, IICPE-2012, Delhi University, pp. 1-6, Dec. 2012. (No. of Citations=7)
20. N. Venkataramana Naik and S. P. Singh, "A Novel Type-2 fuzzy Logic Control of
Induction Motor Drive Using Scalar Control," International IEEE Conf. Proc, IICPE-12,
Delhi University, Dec. 2012(No. of Citations=12)
21. N. Venkataramana Naik and S. P. Singh, "A Novel Type-2 fuzzy Logic Control of
Induction Motor Drive using Space Vector PWM," International IEEE Conf. Proc,
INDICON-12, Kochi, pp. 1142-1147, Dec. 2012. (No. of Citations=5)
22. N. Venkataramana Naik, K. Sri Gowri, and T Brahmananda Reddy, "A Novel
Hybrid Space vector PWM for Reduced Current Ripple Using Scalar Control,"
International Conf. Proc, ICETES-10, Noorul Islam University, Kumaracoil, Mar.
2010. (No. of Citations=2)
23. N. Venkataramana Naik and K. Sri Gowri, "Space Vector Based Hybrid Pulse
width Modulation for Reduced Current Ripple," National Conf. Proc, NCIES-09,
Salem, April. 2009. (No. of Citations=2)

 Total Citations Since 2013: No of Citation: 242, H-index: 8, i10-Index: 6


(from Google scholar link: @
https://scholar.google.co.in/citations?user=Cud1J6AAAAAJ&hl=en )

DST PROJECTS
1. DST project proposal as PI entitled on “An Efficient PV-Fuel Cell Based Hybrid Energy
System for Smart Cities” is submitted to CRG-SERB (CRG/2021/006718/EEC) with a
total cost of Rs. 36,96,800/-
2. DST project proposal as PI entitled on “Design and Development of self-bearing
Permanent Magnet Synchronous Motor drive system” is submitted to ISRO in with a
total cost of Rs. 13,08,000/-

3. DST project proposal as PI on “Design and Control of a Fast and Efficient Electric
Vehicle (EV) Charger for Domestic Installation” EEQ/2021/000886, is submitted
to EEQ-SERB with a total cost of Rs. 49,43,800/-.

4. A Consultancy project proposal entitled on “Design and development on Electric Braking


System for EV applications” submitted to CoE on Electric Mobility in NIT Rourkela

Ph.D. Guidance
 Currently, four candidates on full-time are doing the research work under my
supervision. Out of four, the first two candidates are in the advanced stage to finish
their Ph.D. The remaining two candidates are in the initial stage only.

M. Tech Guidance
1. CHANDAN BEHERA (712EE4082) from PED: Sensorless Control of Brushless DC motor
drive based on Back EMF detection method
2. MARISERLA VINEETH KUMAR (215EE4156) from PED: Study of Induction Motor Drive
With Direct Torque Control Scheme Using Space Vector Modulation and Fuzzy Logic
Controller
3. RAYANA SIVA PAVAN (215EE4162) from PED: Study of Induction Motor Drive with
Indirect Vector Control Using Space Vector Pulse Width Modulation
4. PAGADALA BALAKRISHNA (215EE4252) from PED: Modular Cascaded H-Bridge
Multilevel Inverter with Distributed MPPT for Grid Connected Application
5. PRAKASH KUMAR (713EE3082) from CA: Control of Single Phase Photovoltaic Grid
Connected System
6. BANOTH SURESH (216EE4294) from PED: Sensorless Vector Control of Induction
Motor Based on MRAS Control
7. ESLAVATH LAKPATHI (216EE4304) from PED: Performance Analysis of Shunt Active
Power Filter Using Different Switching Signal Generation Techniques
8. HARISH DORA MONGAM (216EE5320) IE: Performance Analysis of Shunt Active Power
Filter (SAPF) using p-q and d-q theories
9. KAVETI ASHOK KUMAR (713EE3081) from CA: Performance and Anlysis of Three Phase
Photovoltaic Grid Connected System
10. SATYAJEET (217EE4175) from PED: Simulation of cost-effective speed control of BLDC
motor drive
11. CHIRANJEEVI EDIGA (217EE4443) from PED: Design and Development of highly
efficient PFC based AC-DC Driver for AC grid fed LED lighting
12. SHAKTI SOURAV PANDA (715EE4095) from PED: Simulation of Three-phase PMBLDC
Motor from Current controlled Voltage Source Inverter
13. SAIPRAKASH RAO (218EE4159) from PED: Torque Ripple Reduction in BLDC Motor
Using Buck-Boost Converter
14. Bikash Ranjan Panda, ANN based MPPT of solar PV system using boost converter
15. Vishal C Pusadkar, Renewable energy sourced based EV charging station using Sliding
Mode Control
16. Sanjay Kumar Nayak, Modelling and Control of a Grid connected PV system
17. Saurav Kumar Kar, Simulation on Direct Torque Control of Induction Motor Using
SVPWM
18. Dipankar Jena, Design and Simulation of Three Phase Seven Level Inverter Fed
Induction Motor Drive With Three Cascaded H-Bridge Configuration
 Currently, four candidates are doing the M.Tech project work under my supervision.

B.Tech Guidance
No of B.Tech students Guided till now: 14
1. Sibjit Sahoo (112EE0258) and Syed Abrar Ahmed Quadri (112EE0508),"Voltage Sag
Mitigation in Power Distribution Systems" - B.Tech. Supervisor 2015-16 Spring
2. Paul Kujur (113EE0255) and Sai Teja Kolli (113EE0254), "Analysis and Simulation of
Direct Torque Controlled Induction Motor Drive" - B.Tech. Supervisor 2016-17
Spring
3. Waheedullah (113EE0614), "V/F Control of Induction Motor Drive" - B.Tech.
Supervisor 2017 Summer
4. Amrit Mohapatra (114EE0154), Azmeera Harshith Kumar (114EE0439), and Gagan
Kumar Sahu (114EE0166),"Solar PV Based Inverter for Household Pumping Application"
- B.Tech. Supervisor 2017-18 Spring
5. Dhruval Raj Aditya (116EE0288), "Closed loop control of induction motor by v/f method
& Direct torque control of 3 phase 4 switch inverter fed induction motor drive" - B.Tech.
Supervisor 2019-20 Spring
6. Sukumar Dehuri (116EE0302), "Space Vector Pulse Width Modulation Based Boost
Inverter" - B.Tech. Supervisor 2019-20 Spring
7. Bharti Pandit (117EE0380), "Credit Card Fraud Detection Using Machine Learning" -
B.Tech. Supervisor 2020-21 Spring
8. Biswajeet Mohanty (117EE0760), "Design of Multilevel Inverter for Electric Vehicle" -
B.Tech. Supervisor 2020-21 Spring
9. Biswajit Naik (117EE0376), "An enhance hybrid shunt active power filter for non linear
load application" - B.Tech. Supervisor 2020-21 Spring
10. Manish Kumar Nayak (117EE0377), "A Comparative Analysis of PV Based Boost and
Bidirectional DC-DC Converter" - B.Tech. Supervisor 2020-21 Spring
11. Chandan Behera (712EE4082), "Sensorless Control of Brushless DC motor drive based
on Back EMF detection method" - B.Tech. M.Tech Dual Degree Supervisor 2016-17
Spring
12. Prakash Kumar (713EE3082), "Control of Single Phase Photovoltaic Grid Connected
System" - B.Tech. M.Tech Dual Degree Supervisor 2017-18 Spring
13. Kaveti Ashok Kumar (713EE3081), "Three Phase Photovoltaic Grid Connected System" -
B.Tech. M.Tech Dual Degree Supervisor 2018-19 Spring
14. Shakti Sourav Panda (715EE4095), "Simulation of Three-phase PMBLDC Motor from
Current controlled Voltage Source Inverter" - B.Tech. M.Tech Dual Degree Supervisor
2019-20 Spring
15. Dipankar Jena (716EE4098), "Design and Simulation of Three Phase Seven Level
Inverter Fed Induction Motor Drive With Three Cascaded H-Bridge Configuration" -
B.Tech. M.Tech Dual Degree Supervisor 2020-21 Spring
 Currently, three candidates are doing the project work under my supervision.
ADMINISTRATIVE RESPONSIBILITITIES
1. Faculty advisor for the B.Tech in Electrical Engg. Dept., NIT Rourkela from 2016 to
2020
2. PIC of Departmental Infrastructure in Electrical Engg. Dept., NIT Rourkela from July
2018 to 2021
3. Continuing as faculty advisor for the M.Tech PED 2020 batch in Electrical Engg. Dept.,
NIT Rourkela
4. Continuing as PIC of Power Electronics Lab, Electrical Engg. Dept., NIT Rourkela since
2020 July
5. Continuing as PIC of Cleaning and Maintenance, Electrical Engg. Dept., NIT Rourkela
since July 2020
6. Continuing as BOS member for RGMCET, Autonomous, Nandyal, affiliated to JNTU
Anantapur, AP, since 2019

OUTREACH ACTIVITIES
1. Received a Certificate of Appreciation for the sincere review in IEEE International
Symposium on sustainable energy, signal processing and cyber security (IEEE-iSSSC
2020), 16th -17th December 2020, GIET University Gunpur, Orissa state, India.
2. Session Chair in the National Conference JNANA CHILUME-2020 “Automation,
Control and Communication” at Faculty of Engineering and Technology, JAIN
(Deemed-to-be University), on 25th November 2020.
3. An external expert for conducting the final viva voce of M.Tech students in the field of
Power Electronics and Drives, Electrical Engineering Department, SVNIT Surat,
Gujarat, on 20-07-2017
4. On 02.03.2020 (11.30 AM -01.00 PM & 02.00 PM – 03.30 PM), an expert talk was given
on “Space Vector Based Hybrid Pulsewidth Modulation for Reduction of Reduction
of Induction Motor Current Ripples,” for the one week workshop on “Recent Trends
and Advancements in Power Systems and Power Electronics” Mar. 2nd-6th Mar. 2020,
Electrical Engineering Department, NIT Raipur.
5. On 07.11.2020 (09.30 AM -11.00), the expert talk on “Grid Integration of Renewable
Energy Sources,” was given in one week AICTE sponsored Faculty Development
Programme on “Advances in Teaching and Research in the field of Green Energy
and Sustainable Development" during 2nd to 7th November 2020, JNTU Anantapur, AP,
India.
6. Reviewer for 7th IEEE Uttar Pradesh Section International Conference on Electrical,
Electronics, and Computer Engineering (UPCON-2020), November 27-29, 2020, MNIT
Allahabad, Prayagraj, India.
7. Reviewer for 3rd IEEE International Conference on “Recent Developments in Control
Automation and Power Engineering (RDCAPE-2019),” Amity University Uttar
Pradesh,10th -11th October 2019.
8. Reviewer for 9th IEEE Power Electronics, Drives and Energy Systems (PEDES-2020)
International conference 16-19 December 2020, MNIT, Jaipur, Rajasthan, India.
9. On 26-08-2020 at 9:30-11:00, provided an expert speaker on entitled “Multi-level
inverter fed Direct Torque Control of Induction Motor Drive,” Academic-Conduct of
Faculty Development Programme (FDP) on “Recent Advances in Electrical Power
Engineering,” for teaching faculty of Electrical & Electronics Engineering working in
various Govt. Polytechnics from 24/08/2020 to 28/08/2020, Organized by State
Board of Technical Education and Training, Andhra Pradesh.
10. On 24-09-2020 at 2:00PM-3:30PM, contributed an expert speaker on entitled “An
Improved Current Ripple Performance of Induction Motor Drive for an Electrical
Vehicle Applications,” AICTE sponsored STTP on " AICTE-STTP Phase-3 on ”Challenges
in Electric Vehicular Battery Charging & GridIntegration Issues" held during 24-09-2020
to 30-09-2020, 2020 at RGMCET, Autonomous, Nandyal, affiliated to JNTU
Anantapur, AP.
11. On 07-08-2020 at 10:30AM-12:30PM and 2:30PM-4:30PM, contributed an expert
speaker on entitled “Isolated DC-DC Converter for Photovoltaic Electric Vehicle
Applications,” AICTE sponsored STTP on "Challenges in Electric Vehicular Battery
Charging & Grid Integration Issues" held during 03-08-2020 to 08-08-2020, at 2020 at
at RGMCET, Autonomous, Nandyal, affiliated to JNTU Anantapur, AP.
12. On 03-07-2020 at 9:30-11:00, offered an expert speaker on entitled “Multi-level
inverter fed Induction Motor Drive,” the 5-Day National Level FDP on "Recent Trends
in Electric Drives & Control" during 29-06-2020 to 03-07-2020 at RGMCET,
Autonomous, Nandyal, affiliated to JNTU Anantapur, AP.
13. A talk on FDP was “Recent Trends in Power Electronics for Grid Integration of
Renewable Energy Systems” on 2.12.2020 from 10 AM to 12 PM and 2 PM to 4 PM.
Vasireddy Venkatadri Institute of Technology, Autonomous, affiliated to JNTU
Kakinada, AP.
14. Invited lecture or seminar entitled “Advanced Speed Control Methods for Induction
Motors,” was given in Vignan institute of technology and science, Electrical
Engineering department, Hyderabad, Telangana State on 25-July 2019.
15. On 15-11-2018, gave an expert talk on “Investigations on Direct Torque Control of
Induction Motor Drive” A one week Faculty Development Program on “Application of
Artificial Intelligence and Soft Computing Techniques to Electrical Engineering,”
13-17 Nov, 2018,” is given in GVEC, JNTU Kakinada, AP.
16. Since 2019, I was continuing as a BOS member of Rajeev Gandhi Memorial College of
Engineering and Technology, Autonomous, Nandyal, affiliated to JNTU Anantapur.
17. Reviewer for IEEE Transactions on Industrial Electronics, IEEE Transactions on Power
Electronics, Electrical Power Compenents and Systems, IET Power Electronics, IETE
Technical Review, IETE Journal of Research, Solar Energy, and ISA TRANSACTIONS.
18. After selection of Badminton Tournament for doubles in NIT Rourkela, Participated in Inter
NIT Badminton Tournament for doubles at MNIT Jaipur during Dec. 18-20, 2019.
JOB EXPERIENCE
 Assistant Professor with the teaching experience of approximately nine months from 17-
08-2009 to 15-05-2010, GPREC, Kurnool, AP.
 Assistant Professor from 20-08-2015 to 01-02-2018, Electrical Engineering Department,
National Institute of Technology Rourkela.
 Assistant Professor Grade-II from 02-02-2018 to 12-02-2020, Electrical Engineering
Department, National Institute of Technology Rourkela.
 Assistant Professor Grade-I from 13-02-2020 to until now, Electrical Engineering
Department, National Institute of Technology Rourkela.
The subjects/courses have been handled to the students as given below in detail as
Subjects Handled:
1. Basic Electrical Engineering for B.Tech
2. Electric Drives for B.Tech
3. Electrical Machines for B.Tech non-branch
4. Electrical Machines-II for B.Tech
5. Electrical Measurements and Instrumentation for B.Tech
6. Power Electronics for B.Tech non-branch
7. Special Machines for M.Tech
8. Network Theory for B.Tech
 Currently, Electric Drives subject is handled for B.Tech students
Lab Handled:
1. Network Simulation Lab
2. Basic Electrical Engineering
3. Power Electronics and Drives experimentation and Simulation
4. Network Theory
5. Electrical Machines
6. Power System
7. Power System Design
 Having approximately 7 years of teaching experience in the field of Power Electronics
and Drive Control during my Ph.D. at IIT Roorkee.

Thesis
PhDThesis Title: “Investigations on Direct Torque Control of Induction Motor Drive”
Supervisors: Prof. S. P. Singh, Electrical Engineering Department, IIT Roorkee.
Thesis submitted on: 25-08-2015
Defense Date: 03-02-2016
M. Tech Thesis Title: Space Vector Based Hybrid Pulse Width Modulation for Reduced
Current Ripple
B. Tech Thesis Title: Implementation of Multi Featured DSP Based Inverter Fed Induction
Motor with Improved Power Factor

SKILLS AND ACHIEVEMENTS


Computer Languages: C, m-file programming, MATLAB/Simulink, PSIM,
MS Office, PSPICE, DSP, DSPACE, Control Desk, RT-LAB, OPAL-
Software Packages: RT, Lab VIEW, and FPGA.
Languages Known: Telugu (SRW), English (SRW), and Hindi (SRW)
 Received a Certificate of Appreciation for the sincere review for IEEE International
Symposium on sustainable energy, signal processing and cyber security (IEEE-iSSSC
2020), 16th-17th December 2020, GIET University Gunpur, Orissa state, India.
 Ph.D thesis is evaluated with over all A-Grade
 Received fellowship from MHRD during full-time Ph.D. program
 Received fellowship from MHRD during full-time M. Tech program
 GATE 2007 and 2010 is qualified
 Session Chair in the National Conference JNANA CHILUME-2020 “Automation, Control
and Communication” at Faculty of Engineering and Technology, JAIN (Deemed-to-be
University), on 25th November 2020.
 Member of the Student Organizing Committee for CERA-13 IEEE International
conference during Ph.D
 An External Expert for conducting the final viva voce of M.Tech students in the field of
Power Electronics and Drives, Electrical Engineering Department, SVNIT Surat,
Gujarat, on 20-07-2017.
 IEEE Young Professional Member
 IEEE IES Member
 Three manuscripts published in IEEE Transactions on Industrial Electronics with an
impact Factor of 8.236
 One manuscript published in IEEE Transactions on Power Electronics with an impact
Factor of 7.224
 Reviewer for reputed journals like IEEE Transactions on Industrial Electronics, IEEE
Transactions on Power Electronics, Electrical Power Components and Systems, IET Power
Electronics, IETE Technical Review, IETE Journal of Research, Solar Energy, and ISA
Transactions.

EXTRA CURRICULARS
1. A Conference and the Tutorial Classes on 13th IEEE International Conference on
PEDS-2019, Toulouse, France, Participated, July 9-12th, 2019.
2. A Conference and the Tutorial Classes on 10th International Conference on
Computing, Communications and Networking Technologies (ICCCNT-2019), IIT
Kanpur, July 6-8th, 2019.
3. A Conference and the Tutorial Classes on “PEDES-12, International Conference IEEE
Conference,” at Trivandrum, Participated, Dec. 14-17th, 2016.
4. A Conference and the Tutorial Classes on “IICPE-14, International Conference IEEE
Conference,” at NIT Kurukshetra, Participated, Dec. 8-10th, 2014.
5. A QIP program topic on “Multi-level inverter,” at IIT Roorkee, Participated Dec. 2013.
6. A member of the student organizing committee “CERA-13 International Conference IEEE
Conference,” at IIT Roorkee, Participated, 3 -5th Oct. 2013.
7. A Conference and the Tutorial Classes on “INDICON-13 International Conference IEEE
Conference,” at IIT Bombay, Participated, Dec. 13-15th, 2013.
8. A Conference and the Tutorial Classes on “PEDES-12 International Conference IEEE
Conference,” at IISc Banglore, Participated, Dec 16-19th, 2012.
9. A Conference and the Tutorial Classes on “INDICON-12 International Conference IEEE
Conference,” at Khochi, Participated, Dec. 7-9th, 2012.
10. A Conference and the Tutorial Classes on “IICPE-12 International Conference IEEE
Conference,” at Delhi University, Delhi, Participated, Dec. 6-8th, 2012.
11. A Conference and the Tutorial Classes “ICETES-10 International Conference,” at Noorul
Islam University Kumaracoil, Participated, Mar. 25-26th, 2010.
PERSONAL DETAILS:
Father's Name: Permanent Address:
Late N. Pedda Thirupal Naik H.No. 8-64/1,
Mother’s Name: N Kasamma Bai Mustepalli (Village),
Date of Birth: June 9th, 1985 Atmakur (Mandal),
Gender: Male Kurnool (District),
Married/Un-Married: Married Andhra Pradesh-518422
Mobile No.: +918763983981 Current Address: FRB-303, NIT Rourkela,
Email: iitrramana@gmail.com & Rourkela
gpr.ramana@gmail.com Sundergarh (Dt),
Orissa-769008
REFERENCES
1. Dr. S. P. Singh 2. Dr. Mukesh Kr. Pathak
Professor, Electrical Engg. Dept., Professor, Electrical Engg. Dept.,
IIT Roorkee, Uttarakhand-247667. IIT Roorkee, Uttarakhand-247667.
Email:spseefee@gmail.com & Email: mukeshpathak@gmail.com &
spseefee@iitr.ac.in mukesfee@ee.iitr.ac.in
Mobile No.: +91-9411762610 Mobile No.: +91-9458314144
Land line No: +91-1332285827 Land line No: +91-1332285220

DECLARATION:
I hereby declare that the above-furnished details are fully true to the best of my knowledge
and belief.

Date: 24/08/2021
Place: Rourkela (Dr. Venkata Ramana Naik N.)

You might also like