Professional Documents
Culture Documents
Experimental Methods in Engineering II 2021F
Experimental Methods in Engineering II 2021F
Experimental Methods in Engineering II 2021F
* Her gruba ait cevap kağıdını birer pdf dosyası şeklinde hazırlayarak ilgili gruba gönderiniz.
*Ödev bölümünden yüklenememe gibi bir durumla karşılaşmanız durumunda, sınav süresi içinde kalmak
şartıyla Araş.Grv. Nail Aslan’a özel chatten (SOHBET KISMI) gönderebilirsiniz. Cevap kağıtlarınızı
herkesin görebileceği şekilde KESİNLİKLE GÖNDERMEYİNİZ.
*Teams’de sorun olmasından kaynaklı ödev bölümünden gönderilememesi durumunda, sınav süresi
içinde olması kaydıyla nail.aslan@cbu.edu.tr adresine gönderebilirsiniz.
*Cevap kağıtlarınızı UBS’de kayıtlı olduğunuz öğrenim gruplarına (örgün veya ikinci öğretim)
gönderiniz.
*Sınav süresince her grupta linki paylaşılan bir toplantı mevcut olacaktır.
C.B.Ü ENGINEERING FACULTY
DEPARTMENT OF MECHANICAL ENGINEERING
MEE4165-EXPERIMENTAL METHODS IN ENGINERRING II FINAL EXAM
Date 03.02.2021
Duration
Name-Surname :
Number:
QUESTIONS: (Materials)
GOOD LUCK!
Prof. Dr. Nurşen SAKLAKOĞLU
C.B.Ü ENGINEERING FACULTY
DEPARTMENT OF MECHANICAL ENGINEERING
MEE 4165-EXPERIMENTAL METHODS IN ENGINERRING II FINAL EXAM
Date 03.02.2021
Duration
Name-Surname :
Number:
QUESTIONS: (Energy)
1. A 0.5-m3 rigid tank contains refrigerant-134a initially at 160 kPa and 40 percent quality.
Heat is now transferred to the refrigerant until the pressure reaches 700 kPa. Determine (a) the
mass of the refrigerant in the tank and (b) the amount of heat transferred. Also, show the
process on a P-v diagram with respect to saturation lines.
2. A refrigerator uses refrigerant-134a as the working fluid and operates on an ideal vapor-
compression refrigeration cycle between 0.12 and 0.7 MPa. The mass flow rate of the
refrigerant is 0.05 kg/s. Show the cycle on a T-s diagram with respect to saturation lines.
Determine (a) the rate of heat removal from the refrigerated space and the power input to the
compressor, (b) the rate of heat rejection to the environment, and (c) the coefficient of
performance.
GOOD LUCK!
Dr. Ayşegül Güngör Çelik
C.B.Ü ENGINEERING FACULTY
DEPARTMENT OF MECHANICAL ENGINEERING
MEE4165-EXPERIMENTAL METHODS IN ENGINERRING II FINAL EXAM
Date 03.02.2021
Duration
Name-Surname :
Number:
QUESTIONS: (Mechanics)
1. What is FFT analysis? Why we need to used this analysis? Give some information about
FFT analysis.
2. A solid steel bar of circular cross section has diameter d=40 mm, length L=1.4 m, and shear
modulus of elasticity G=80 GPa. The bar is subjected to torques T acting at the ends. If the
torques have magnitude T= 340 N.m, what is the maximum shear stress in the bar? What is
the angle of twist between the ends?
.
∅= = =
.
GOOD LUCK!
Dr. Ayşegül Güngör Çelik