Professional Documents
Culture Documents
ARL-700 Firmware Update.V120.en
ARL-700 Firmware Update.V120.en
20
ARL-700
ELEVATOR CONTROLLER FOR TRACTION & HYDRAULIC LIFTS
(COMPATIBLE FOR EN81-20)
FIRMWARE UPDATE
ARL-700 Firmware Update V1.20
This document has been created to be a guide for Arkel customers. Reproduction, transfer, distribution or storage of part or
all of the contents in this document in any form without the prior written permission of Arkel is prohibited. Arkel reserves
the right to make changes and improvements to any of the products described in this document without prior notice.
Arkel is not responsible for those mistakes that may be found in this manual and for the damages that they may cause.
ARL-700 Firmware Update V1.20
Content
Content .......................................................................................................................................................................................... 3
1. Downloading Firmware File ............................................................................................................................................... 4
2. Copying Firmware File to SD Card ................................................................................................................................... 5
3. Firmware Update Process ................................................................................................................................................... 6
3.1. Firmare Update by using Arem Hand Terminal: .................................................................................................... 6
3.2. Firmware Update by ARL-700 Keypad: .................................................................................................................. 7
ARL-700 Firmware Update V1.20
• Click “TECHNICAL SUPPORT” from Menu bar and follow below steps.
• After logging In, from "Software "menu go to "ARL700 Elevator Control Board "→"System Firmwares "
→”ARL700 Firmwares (as seperate downloads)” (as below picture)
• Scroll down until you find the latest firmware version on the bottom of list then download it.
ARL-700 Firmware Update V1.20
• At "firmware " directory paste firmware version file (with “.ars” extinction ) that you downloaded at section 1.
Note: You can see all version of ARL700/Arcode Firmware versions on “firmware” directory.
• Then if it is SD card, after plugging it to Arem Hand terminal make go to section 3.1. and make update, if it is Micro
SD card, after plugging it to ARL700 device go to Section 3.B and make update.
• From "firmware update" Select the latest version whitchs located on the top of version list.
Note: according version releasing date that you downloaded to SD card, you will see the version date on Arem firmware
update screen.
ARL-700 Firmware Update V1.20
• Press "Enter" button on AREM Handset, then you will see confirmation message select "Yes" to start updating procces.
Warning 1: Don't plug out AREM Handset socket during update process on (Section 3).
Warning 2: Before starting update process (section 3), don't forget to connect all peripherals witch are communicating with
Arcode through Can Bus. Otherwise ARL-700 won't be able to identify them later.
Note: In case of power shutdown during update procces. you should repeat Section 3 again after powering the system.
3.2. Firmware Update by ARL-700 Keypad:
Press Right Direction button on keypad (White button beside yellow and red buttons) for
several times (18 times).
Then you should find (“SD Card operations”) as shown on below parameters:
3. PRESS enter ( ) to select firmware version. 4- PRESS UP/DOWN direction buttons ( ) to select
3- firmware version. Then press enter ( )
Note: In case of power shutdown during update procces. you should repeat Section 3 again after powering the system.