Professional Documents
Culture Documents
Conlab Tansduser Datasheet
Conlab Tansduser Datasheet
TRANSDUCER
ACCURACY OF ±0.1%
AC CURRENT INPUT
AC VOLTAGE INPUT
COMPLETE ISOLATION
LOW COST
3 YEAR WARRANTY
The ACT-4I3P and the ACT-4V3P isolated Wide input current ranges are obtained by
four-wire transducers accept AC current/ means of changing one resistor for coarse
voltage input signals and generate a range setting. This resistor is located on the
proportional 4-20mA process output current. inner printed circuit board.
Accurate, full-wave squaring circuitry is Fine tuning is achieved via the "Zero" and
applied for true conversion of the AC input "Span" multi-turn potentiometers located on
signal into an accurate isolated output. the inner printed circuit board.
For complete safety, internal transformers The ACT-4I3P and the ACT-4V3P units can
isolate the input and enable the ACT-4I3P powered either by 220/110Vac or by
and the ACT-4V3P to withstand large 22 - 66Vdc.
momentary input signals.
Complete input to output galvanic isolation, The ACT-4x3P transducers are housed in a
high surge current capacity and high output polycarbonate plastic enclosure mounted on
signal to noise ratio, makes the Series 4 a standard DIN rail side by side, with no
highly immune to ground loop signals and wasted space in high density installations.
RFI.
ACT-4I3P and ACT-4V3P SPECIFICATIONS
ACT-4V3P ACT-4I3P
INPUT SPAN (factory set): 0 - 600 Vac RMS INPUT SPAN: 0 - 1 to 0 - 10 Aac (RMS)
WEIGHT: 0.9 Kg
Connection Diagrams
Dimensions
Ordering Information
ACT-4-I-3P-5- 4-20-1-2-S
Product Type
I-current/V-voltage
Max Input Range
Output Current
Input Freq. 1-50, 2-60
Supply (1- 110, 2-220 Vac, 3- Vdc)
S - -20 to 70°C / E- -30 to 80°C