Professional Documents
Culture Documents
Data Communication Project For 4th Year ECE Student
Data Communication Project For 4th Year ECE Student
Device information
Device Interface Ip address Subnet mask Default
gateway
Router1 Fa0/0 192.168.1.1 255.255.255.0 N/A
Se0/0/0 192.168.2.1 255.255.255.0 N/A
Router2 Se0/0/0 192.168.2.2 255.255.255.0 N/A
Se0/0/1 192.168.3.1 255.255.255.0 N/A
Fa0/0 192.168.5.1 255.255.255.0 N/A
Router3 Se0/0/0 192.168.3.2 255.255.255.0 N/A
Fa0/0 192.168.4.1 255.255.255.0 N/A
Pc0 N/A 192.168.1.2 255.255.255.0 192.168.1.1
Pc1 N/A 192.168.1.3 255.255.255.0 192.168.1.1
Pc2 N/A 192.168.5.2 255.255.255.0 192.168.5.1
Pc3 N/A 192.168.5.3 255.255.255.0 192.168.5.1
Pc4 N/A 192.168.4.2 255.255.255.0 192.168.4.1
Pc5 N/A 192.168.4.3 255.255.255.0 192.168.4.1
Tasks
Task 1: Cable the Network
What type of cable is used to connect the Ethernet interface on a host PC to the Ethernet interface
on a switch? ___________
What type of cable is used to connect the Ethernet interface on a switch to the Ethernet Interface
of router?
What type of cable is used to connect the Ethernet interface of two different routers?
Task 2: Perform Basic Configuration of Router R1.
Task 3: Perform Basic Configuration of Router R2.
Task 4: Perform Basic Configuration of Router R3.
Task 5: Configure IP Addressing on the Host PCs.
Task 6: Verify and Test the Configurations.
Task 7: verify the connectivity between hosts using ping command.
Exercise : As the figure shown below four routers connected together to transfer
data from different computer and try to send packet from those different
computers.
Group Two
Network topology
Tasks
Task 1: Cable the Network
What type of cable is used to connect the Ethernet interface on a host PC to the Ethernet interface
on a switch? ___________
What type of cable is used to connect the Ethernet interface on a switch to the Ethernet Interface
of router?
What type of cable is used to connect the Ethernet interface of two different routers?
Task 2: Perform Basic Configuration of Router R1.
Task 3: Perform Basic Configuration of Router R2.
Task 4: Perform Basic Configuration of Router R3.
Task 5: Configure IP Addressing on the Host PCs.
Task 6: Verify and Test the Configurations.
Task 7: verify the connectivity between hosts using ping command.
Exercise 3: As the figure shown below four routers connected together to transfer data
from different computer and try to send packet from those different computers.
Group Four
Network topology