Professional Documents
Culture Documents
Afiche Triseal 2009 Intercambios y Guia de Instalacion
Afiche Triseal 2009 Intercambios y Guia de Instalacion
Assemble all required parts and Thoroughly prepare all surfaces that Thoroughly clean and inspect the Do not install seals with wheel For installing Triseal two-piece seal Select correct Triseal seal installation
installation tools. mate with seals and axle nut. entire hub, inside and out. assembly in vertical position. axle sleeves, see steps 13 to 16. tool driver and bearing guide.
Step 1: Triseal Oil Bath Seals, tools, Step 2: Remove all corrosion, old Step 3: Remove all rust, scale and burrs Step 4: Place wheel assembly flat on Step 5: Clean and inspect bearings, Step 6: Use each manufacturers tools on
new gasket, torque wrench, and dial sealant, and sharp edges, clean and from all seal related surfaces. floor or at a 45 degree angle. lubricate with wheel-end lubricant. their seals only, they do not interchange.
indicator. inspect spindle threads.
Carefully align tool/seal assembly Drive seal into bore only until the Lubricate the seal with the same For installing drive axles, see tips Fully install hub. Lubricate outer Use of a torque wrench and dial
with the inner bearing. tool rebounds and sound changes. lubricant to be used in the hub. section below. bearing and install. indicator is critical.
Step 7: Use the inner bearing as a guide Step 8: Use a 3-5 lb. hammer. Do not Step 9: Use only the same wheel-end Step 10: Use wheel dolly only. Align hub Step 11: Install adjusting nut and tighten Step 12: Adjust the wheel bearing to the
for tool/seal assembly. over-drive the seal. Failure will result lubricant in hub. with spindle and slide on part way. Fill slightly. Remove wheel dolly. axle nut manufacturers specifications or
from damage. hub with lubricant. to TMC recommendations.
Installing Tips
s $O NOT USE SEALANTS ON THE SEAL /$ On Trailer Axles:
s !LWAYS PRE
LUBRICATE WITH THE SAME s $O NOT EXCEED THE OIL LEVEL LINE ON
lube to be used in the hub the hubcap window
s )F USING GREASE TO LUBRICATE THE On Drive Axles:
wheel bearings on non-driven axles, s 2AISE THE WHEEL
END APPROXIMATELY
see vehicle manufacturer or TMC 8 inches for 1 minute and repeat for
recommendations the other side. Remove the axle fill
plug, and add lubricant as needed.
Remove the axle breather, clean in
Remove old axle sleeve with ballpeen Remove any gouges or marring from Use only Triseal axle driver and drive Inspect for full installation, remove solvent. Dry with compressed air,
hammer. Do NOT use a chisel. axle shoulder with a file. plate. all excess RTV. and re-install.
Step 13: Use a hammer on the back Step 14: Apply thin film of non- Step 15: Drive axle sleeve on to shoulder Step 16: Sleeve must be fully installed
of a severe service sleeve or face of a hardening RTV on the axle shoulder only. until the tool rebounds. and flush with shoulder.
standard sleeve. Return to step 6. Seal in Seal Bore Seal in Bearing Bore