Professional Documents
Culture Documents
9883511790ENUWA
9883511790ENUWA
9883511790ENUWA
5.1.1
This machining center is used to process parts for furniture, components made of wood, or
materials similar to wood.
Features Values
Contents:
1 Maintenance work 2
1.1 Lubricating the axles..................................................................................................3
1.2 X axis .........................................................................................................................4
1.3 Y axis .........................................................................................................................5
1.4 Z axis .........................................................................................................................6
1.5 Drilling gear ...............................................................................................................7
1 Maintenance work
Proceed as follows
Note:
Clean all lubrication nipples thoroughly
before greasing. Dirt must not enter the
lubricating nipple openings.
Caution:
Dry end seals and/or dry bearing surfaces
on the guide are indicative of insufficient
lubrication. It is imperative that the
components are lubricated, reduce
lubrication interval!
1.2 X axis
Proceed as follows
Note:
To reach lubricating nipples 1.1:
Move the clamp to the right-hand park
position
Open flap 1.2.
1.3 Y axis
Proceed as follows
Lubricant WEEKE
special lubricant
order no. 4-017-02-0035
Qty. 2 pumps / nipple
Timeframe 100 hours
Grease gun 2-001-95-0600
Note:
The Y axis must be moved to the
maintenance position in order to reach the
lubricating nipples.
1.4 Z axis
Proceed as follows
3.1
pumps of grease per lubricating nipple
Remove any grease that escapes
Lubricant WEEKE
special lubricant
order no. 4-017-02-0035
Qty. 2 pumps / nipple
Timeframe 100 hours
Grease gun 2-001-95-0600
Note:
The Y axis must be moved to the
maintenance position in order to reach the
lubricating nipples.
Proceed as follows
Lubricant WEEKE
special lubricant
order no. 4-017-02-0035
Qty. 2 pumps / nipple
Timeframe 500 hours
Grease gun 2-001-95-0600
Note:
The Y axis must be moved to the
maintenance position in order to reach the
lubricating nipple. T:\\9883\\511790\\X004.jpg