To design a steel structure using SAP software, first define a standard cross-section, draw the geometry, define load combinations, run the model, design the steel frame, verify and re-run the design until no elements remain, then manually reassign sections instead of using the automatic section assignment.
To design a steel structure using SAP software, first define a standard cross-section, draw the geometry, define load combinations, run the model, design the steel frame, verify and re-run the design until no elements remain, then manually reassign sections instead of using the automatic section assignment.
To design a steel structure using SAP software, first define a standard cross-section, draw the geometry, define load combinations, run the model, design the steel frame, verify and re-run the design until no elements remain, then manually reassign sections instead of using the automatic section assignment.
1- Define a frame section called "Auto" this section includes
any section that you may use from the standard sections. 2- Draw the geometry 3- Define the combinations manually or using the auto combination 4- Run the model 5- Click on design then steel frame design 6- Click on design then verify the run again 7- Repeat the last step until the message gives zero elements 8- Reassign the sections manually instead of the auto section. 9-