Professional Documents
Culture Documents
Tegostab B 8465
Tegostab B 8465
Technical Information
TEGOSTAB® B 8465
The solidification point of TEGOSTAB® B 8465 is As a consequence of this combination the use of
about -20 °C. Apart from increased viscosity, no TEGOSTAB® B 8465 is beneficial even in formu-
further changes of this stabilizer's consistency are lations blown with low boiling blowing agents,
therefore observed at 0 °C. It is, however, recom- because better control of the “frothing effect” is
mended to adapt the temperature of undercooled ensured.
material to normal ambient temperature before
In any case the resulting foams are characterized
use.
by a reduced tendency to form cavities, a parti-
For TEGOSTAB® B 8465 we guarantee a shelf life cularly fine cell structure and a high amount of
of at least 12 months upon delivery under the closed cells.
condition that it is stored in factory-sealed con-
The applied concentration of TEGOSTAB®
tainers and protected against extreme weather
B 8465 should be between 1.0 and 2.0 parts
conditions, particularly against heat and moisture.
per 100 parts polyol.
Application
Packaging
TEGOSTAB® B 8465 is soluble in most of the
840 kg pallet (4 x 210 kg in steel drums)
commonly applied rigid foam polyols. The
1 000 kg plastic containers
resulting solution is clear. TEGOSTAB® B 8465 is
mainly applied in polyurethane rigid foam
systems which predominantly blown with alter-
native blowing agents such as HCFC or HFC.
Legal References
This information and all further technical advice is based on our present knowledge and experience. However, it implies no liability or
other legal responsibility on our part, including with regard to existing third party intellectual property rights, especially patent rights.
In particular, no warranty, whether express or implied, or guarantee of product properties in the legal sense is intended or implied. We
reserve the right to make any changes according to technological progress or further developments. The customer is not released from
the obligation to conduct careful inspection and testing of incoming goods. Performance of the product described herein should be
verified by testing, which should be carried out only by qualified experts in the sole responsibility of a customer. Reference to trade
names used by other companies is neither a recommendation, nor does it imply that similar products could not be used.
07/2010
Evonik Industries AG Goldschmidtstraße 100 45127 Essen/Germany
Phone +49 201 173-2466, Fax +49 201 173-1991
polyurethane@evonik.com, www.evonik.com/polyurethane-additives