Professional Documents
Culture Documents
Tds Yieh 5052 Plate Sheeets
Tds Yieh 5052 Plate Sheeets
Aluminum 5052 is a 5000-series aluminum alloy with higher amount of magnesium content comparing
with 5005, and it is one of the higher strength non-heat treatable alloys (Annealed it is stronger than 1100,
3003 and 5005). Alloy 5052 has excellent characteristics with a high fatigue strength it is used for
structures which are subject to excessive vibrations. As 5052 also has excellent corrosion resistance,
especially in marine atmospheres, and it is therefore commonly used in boats, marine components, fuel
and oil tubing.
Alloy: 5052
Form: Plate
Temper: O, H111, H112
Dimension: Thickness: 6.0mm to 80mm
Width: 1,000mm to 2,500mm
Length: 3,000mm to 10,000mm
Surface Finish: Mill Finish
Standard Specification: GB/T 3880, ASTM B209, EN 485
Application: General Use
CHEMICAL COMPOSITION:
ALUMINUM.YIEH.COM
MECHANICAL PROPERTIES:
PHYSICAL DATA :
ALUMINUM.YIEH.COM
Length Thickness Length
Tolerance: ≤ 2000mm > 2000~3000mm > 3000~4000mm > 4000
≥ 6~80mm + 7mm + 8mm + 9mm + 10mm
OTHER PROPERTIES:
Principal Design Features This is a non-heat treatable alloy that is weldable. It is hardened by cold
work. It has good forming characteristics and good corrosion resistance,
including resistance to salt water.
Machinability This alloy has relatively fair machinability. It is easier to machine in the hard
temper than as annealed and the quality of finish is better if machined in the
hard condition. Oil lubricants should be used for machining, except that very
light cuts may be done dry.
Forming Aolly 5052 is readily formed at room temperature. Successive cold working
decreases the formability.
Weldability This alloy is readily welded by conventional methods. When filler rod is
required it should be aluminum alloy 5356 as filler. Either tungsten or
consumable electrode inert gas shielded arc welding is preferred method.
Heat Treatment Alloy 5052 cannot be hardened by means of heat treatment. It does harden
due to cold working.
Hot Working This alloy has excellent cold working characteristics such that hot working
should not normally be necessary. However it may be hot worked in the
temperature range of 260°C to 510°C.
ALUMINUM.YIEH.COM
Cold Working The alloy cold works readily and may be formed by drawing or spinning.
However the amount of cold work imparted by spinning makes intermediate
annealing necessary.
Annealing Annealing, if required, may be done at 345°C, followed by air cooling.
Hardening Only cold working will cause hardening (strengthening) of this alloy as it
does not harden by heat treatment.
APPLICATIONS
The above mentioned aluminum product is produced according to national standard specifications, and has
no poison, no pollution, and no cauterization. It is common industry metal material.
ALUMINUM.YIEH.COM