Professional Documents
Culture Documents
Loctite Liofol BC 1582-En
Loctite Liofol BC 1582-En
Preamble in TDS: Siegwerk & Henkel jointly developed the Typical Properties
following product and made it subject of a joint patent Typical oxygen transmission rate (OTR) values on film for
application. Both sides will commercialize the product under laminates of coated films, having a coating layer of ca. 0.7 g/m²
the name CIRKIT OxyBar 1582 and LOCTITE LIOFOL BC (dry) measured at different relative humidities (r.h.).
1582. The products are to be considered identical.
OTR at 23 °C and 1 bar measured in [cm³/(m² 24 h)]:
PRODUCT DESCRIPTION
Plain film Coated film Coated film
LOCTITE LIOFOL BC 1582 has the following product (0% r.h. / (0% r.h. / (75% r.h. /
characteristics: 0% r.h.) 0% r.h.) 50% r.h.)
PET 120 <5 ~5
Technology Water-based blended with solvent
OPP >1.000 <20 <30
Product Type Oxygen barrier coating
PET/AIOx 2.5 <1 <5
Condition Water-based, contains ethanol
Components One-component
Application Barrier coating
Cure Not applicable Compliance with food packaging regulations:
Appearance Clear to slightly hazy, liquid Under specific conditions LOCTITE LIOFOL BC 1582 is
suitable for the manufacture of food packaging materials
under the applicable FDA, EU-provisions and/or BfR
Application Areas: recommendations.
LOCTITE LIOFOL BC 1582 provides a barrier coating which
can be subsequently laminated. LOCTITE LIOFOL BC 1582 A food contact statement with further details is available on
is designed for flexible packaging applications such as nuts, request.
confectionery, snacks, pet food, bakery, spices and The responsibility for compliance with the specific conditions
seasoning. This coating is suitable for lamination with solvent is with the converter and not with the adhesive supplier.
based and solvent free adhesives.
DIRECTIONS OF USE
Product Properties: Preliminary Statement:
LOCTITE LIOFOL BC 1582 is a barrier coating which Prior to application it is necessary to read the Safety Data
provides good oxygen barrier properties to flexible Sheet for information about precautionary measures and
substrates. It is a chlorine-free coating. The applied coating safety recommendations. Also, for chemical products exempt
is clear, odor free and elastic. from compulsory labeling, the relevant precautions should
always be observed. Please also refer to the local safety
instructions and contact Henkel for analytical support.
TECHNICAL DATA
LOCTITE LIOFOL BC 1581: Caution
Solid Content, % 14.2 to 17.2 Due to the wide variability of film additives, materials, surface
conditions, process conditions and performance criteria,
Viscosity, Brookfield, mPas 50 to 200 pretesting on your substrates and production equipment is
required to determine if this adhesive system will meet all
Solvent Water, blended
with ethanol your needs.
Application: Classification:
LOCTITE LIOFOL BC 1582 is a single component system, Please refer to the corresponding safety data sheets for
which is delivered ready to use. It does not have a pot life, details on:
but precautions might be necessary to prevent gelation on Hazardous Information
the surface. It is highly recommend to discard of used Transport Regulations
batches appropiately. Safety Regulations
Application Weight:
The recommended dry coating weight of the LOCTITE
LIOFOL BC 1582 is in the range of approximately 0.5 to 1.0
g/m², depending on the oxygen barrier level. In the most
flexible packaging applications a coating weight of 1 g/m²
provides the desired functionality.
Drying:
Optimum drying conditions are dependent on the specific
machine speed, coating weight, dwell time, and efficiency of
the dryer. A system with good air volume and exhaust is
more effective than extremely high temperature to remove
the solvents.
Cleaning:
Wet coating remnants and application equipment should be
cleaned with water. Exposure of the coating to solvent will
cause coagulation. However, dried material may be removed
with a water/detergent mixture or solvent.
STORAGE
When stored in a dry and cool place in the original unopened
container storage life is as follows.
Shelf life:
Shelf-life (in unopened original packaging), months 6
Refer to expiry date on original packaging.
Frost-Sensitive Yes
Recommended storage temperature, °C 5 to 25
Disclaimer
The information provided in this Technical Data Sheet (TDS) including the
recommendations for use and application of the product are based on our
knowledge and experience of the product as at the date of this TDS. The
product can have a variety of different applications as well as differing
application and working conditions in your environment that are beyond our
control. Henkel is, therefore, not liable for the suitability of our product for the
production processes and conditions in respect of which you use them, as well
as the intended applications and results. We strongly recommend that you
carry out your own prior trials to confirm such suitability of our product. Any
liability in respect of the information in the Technical Data Sheet or any other
written or oral recommendation(s) regarding the concerned product is
excluded, except if otherwise explicitly agreed and except in relation to death
or personal injury caused by our negligence and any liability under any
applicable mandatory product liability law.
Trademark usage
Except as otherwise noted, all trademarks in this document are trademarks of
Henkel Corporation in the U.S. and elsewhere. ® denotes a trademark
registered in the U.S. Patent and Trademark Office.
Reference 0.0
Henkel AG & Co. KGaA Henkel Corporation Henkel Diadema Henkel (China) Co.Ltd. Henkel Jebel Ali FZCO
40191 Düsseldorf, Germany Cary, NC 27511, USA Diadema - SP, Brasil 201203 Shanghai, China Dubai, UAE
Phone: +49-211-797-0 Phone: +1-919-319-1933 Phone: +55-11-3205-8955 Phone: +86-21-2891-8000 Phone: +971-4-3893333