Professional Documents
Culture Documents
lm2903 en Ar
lm2903 en Ar
LM2903
Related products
devices with higher ESD performances •
See the LM2903W for similar
with operating temperature up to 150 °C •
See the LM2903H for similar devices
Description
from split power supplies is also possible.
supply over a wide range of voltages. Operation
designed specifically to operate from a single
of two independent lowpower voltage comparators
This device consists
operated from a single power supply voltage.
range includes the negative rail even though
in that the input common-mode voltage
In addition, the device has a unique characteristic
Features
dual supplies +2 V to +36 V or ±1 V to ±18 V •
Wide single supply voltage range or
of supply voltage )1 mW/comparator at +5 V( •
Very low supply current )0.4 mA( independent
Low input bias current: 25 nA typ. •
Low input offset current: ±5 nA typ. •
-mode voltage range includes negative rail •
Input common
voltage: 250 mV typ. )I •
= 4 mA(O Low output saturation
input voltage range equal to the supply voltage •
Differential
compatible outputs •
TTL, DTL, ECL, MOS, CMOS
Automotive qualification •
Contents
Schematic diagram. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 1
Electrical characteristics. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 4
Package information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 6
6.1 SO8 package information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.2 TSSOP8 package information
14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.3 MiniSO8 package information
15. . . . . . . . . . . . . . . . 6.4 DFN8 2x2 package mechanical data )LM2903Q2T(
17. . . . . . . . . . . . . . . 6.5 DFN8 2x2 package mechanical data )LM2903YQ3T(
Ordering information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 7
Revision history. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 8
Schematic diagram 1
Non-inverting
input
Inverting
input
5 .1 - + CC0
to V Common mode input voltage range
V icmV
+
2-CC 0 to V maxT ≥amb T ≥min T
°C - 40 to +125 Operating free-air temperature range operT
Electrical characteristics 4
- TCC = 5 V, VCC+Table 3. V
= 25°C )unless otherwise specified(amb = GND,
Unit Max. Typ. Min. Parameter Symbol
V +V
CC (3)Differential input voltage idV
µs 1.3 ( +
CC= 5.1 kΩ to VL )R (4)Small signal response time rest
from 5 V to 30 V, and over the full input common-mode rangeCC += 0 Ω with V S 1.4 V, R ≈O 1. At output switch point, V
–1.5 V(.CC+)0 V to V
is essentially constant, independent of the state of the output, so no loading charge exists on the reference of input lines.
2. The direction of the input current is out of the IC due to the PNP input stage. This current
within the common-mode range, the comparator provides a proper output state. The low input voltage state must not be less than
3. Positive excursions of input voltage may exceed the power supply level. As long as the other voltage remains
– 0.3 V )or 0.3 V below the negative power supply, if used(.
4. The response time specified is for a 100 mV input step with 5 mV overdrive.
5. Maximum values are guaranteed by design and evaluation.
Figure 4. Input current vs. supply voltage Figure 3. Supply current vs. supply voltage
Figure 6. Response time for various input Figure 5. Output saturation voltage vs. output
overdrives - negative transition current
5V
= 5 VCC V
100 kΩ 15 kΩ
+V
)ref( +V
)ref(
& 2 /1 1/2
LM2903 O
V LM2903
-V
)ref(
-V
)ref(
15 kΩ
1/2 10 kΩ
LM2903 +V
)ref(
e ~ 2 /1
l
&
o
e LM2903
-V
0.5 μF 100 kΩ )ref(
&
1 kΩ
A =100
V
Figure 13. Transducer amplifier Figure 12. Low frequency op-amp with boost
5V 5V
)e =l 0 V for e = 0o V(
3 kΩ 10 kΩ agnetic pick-up
15 kΩ
2 /1
2 /1 2N2222 LM2903
e
o LM2903 e ~
0.5 μF l
20 MΩ
100 kΩ
e
10 kΩ o 1 kΩ
A =100
V
Figure 15. Zero crossing detector Figure 14. Low frequency op-amp with offset
)single power supply( adjust
5V 5V
5.1 kΩ 5.1 kΩ R R
15 kΩ 1 S
l
e
2 /1
2 /1 2222 2N LM2903 ~ le
LM2903
1N4148 0.5 μF
R1
100 kΩ
1 kΩ
20 MΩ
e
10 kΩ o
10 kΩ S
2R
V
5.1 kΩ
)ref(
2 /1 high
LM2903
Lamp
1/2 R
e
o LM2903
S
~ e
I
~ I
e
15 V 1/2
2N2222 LM2903
S
2R
)ref(
V
low
Figure 19. Comparator with a negative Figure 18. Crystal controlled oscillator
reference
= 15 VCC V
15 V
2 kΩ 200 kΩ
100 kΩ
5.1 kΩ CC
V
0 1/2
e
o LM2903 . 1 μF
1/2
o
e LM2903
~ I
5V f = 100 kHz
200 kΩ
15 V
= +15VC CV
3 kΩ 200 kΩ 10 kΩ 15 kΩ
10 MΩ
10 kΩ
CCV 1/2
03
V LM2903
t 3V
3
t o
3 kΩ
10 MΩ
51 kΩ 10 kΩ
10 kΩ
C1V 1/2
LM2903 CCV
1/2
CCV V 0
O2 LM2903 t t
2V
A o
2
t o
t )ref.(V
1/2
CCV O1V LM2903 3V
2VC1 V
t
1
t
0 1V
1V
51 kΩ
t 0
4t 3t 2t 1t 0t
100 kΩ
3 kΩ 3 kΩ 500 pF
5.1 kΩ 2 /1
Frequency control
LM2903 10 kΩ
2 /1 voltage input
Output1 LM2903 0.01 μF Vcontrol
0.1 μF
2/ CC
V
20 kΩ
Output2
20 kΩ 50 kΩ
2/ CC
V
2 /1
LM2903
= + 30 VCC V
+ 50 V Vcontrol + 250 mV
fo 100 kHz 700 Hz
Package information 6
Inches mm Ref.
0.069 1.75 A
0.010 0.004 0.25 0.10 A1
0.049 1.25 A2
0.019 0.011 0.48 0.28 b
0.010 0.007 0.23 0.17 c
0.197 0.193 0.189 5.00 4.90 4.80 D
0.244 0.236 0.228 6.20 6.00 5.80 E
0.157 0.154 0.150 4.00 3.90 3.80 E1
0.050 1.27 e
0.020 0.010 0.50 0.25 h
0.050 0.016 1.27 0.40 L
0.040 1.04 L1
8° 1° 8° 1° k
0.004 0.10 ccc
Inches mm Ref.
0.047 1.20 A
0.006 0.002 0.15 0.05 A1
0.041 0.039 0.031 1.05 1.00 0.80 A2
0.012 0.007 0.30 0.19 b
0.008 0.004 0.20 0.09 c
0.122 0.118 0.114 3.10 3.00 2.90 D
0.260 0.252 0.244 6.60 6.40 6.20 E
0.177 0.173 0.169 4.50 4.40 4.30 E1
0.0256 0.65 e
8° 0° 8° 0° k
0.030 0.024 0.018 0.75 0.60 0.45 L
0.039 1 L1
0.004 0.10 aaa
Inches mm Ref.
0.043 1.1 A
0.006 0 0.15 0 A1
0.037 0.033 0.030 0.95 0.85 0.75 A2
0.016 0.009 0.40 0.22 b
0.009 0.003 0.23 0.08 c
0.126 0.118 0.11 3.20 3.00 2.80 D
0.203 0.193 0.183 5.15 4.90 4.65 E
0.122 0.118 0.11 3.10 3.00 2.80 E1
0.026 0.65 e
0.031 0.024 0.016 0.80 0.60 0.40 L
0.037 0.95 L1
0.010 0.25 L2
°8 °0 °8 °0 k
0.004 0.10 ccc
Inches mm Ref.
Inches mm Ref.
Ordering information 7
TSSOP8
2903Y (1)LM2903YPT
)automotive grade( - 40 °C to +125 °C
K431 Tape and reel MiniSO8 LM2903ST
MiniSO8
K419 (1)LM2903YST
)automotive grade(
DFN8 2x2 mm
K5M (1)LM2903YQ3T
wettable flanks
AEC Q100 and Q003 or equivalent, advanced screening according to AEC Q001 & Q 002 or equivalent.
1. Qualified and characterized according to
Revision history 8
PPAP references inserted in the datasheet see table order code p1. 2 2-May-2005
page.Table 3 on page 5Electrical characteristics table corrected )see
(. Pin connections diagram moved to cover 3 8-Aug-2005
Lead-free package information added.
information on ST products before placing orders. ST products are sold pursuant to ST’s terms and conditions of sale in place at the time of order
improvements to ST products and/or to this document at any time without notice. Purchasers should obtain the latest relevant
STMicroelectronics NV and its subsidiaries )“ST”( reserve the right to make changes, corrections, enhancements, modifications, and
cknowledgement.
for the choice, selection, and use of ST products and ST assumes no liability for application assistance or he design of Purchasers’ products.
urchasers are solely responsible
esale of ST products with provisions different from the information set forth herein shall void any warranty granted by ST for such product.
owners. .www.st.com/trademarksT and the ST logo are trademarks of ST. For additional information about ST trademarks, please refer to
All other roduct or service names are the property of their respective
nformation in this document supersedes and replaces information previously supplied in any prior versions of this document.