Professional Documents
Culture Documents
Ally Herbicide MTR AGHS EN
Ally Herbicide MTR AGHS EN
Ally® Herbicide
Version 1.0
This SDS adheres to the standards and regulatory requirements of Canada and may not meet the regulatory requirements in
other countries.
Eyes
Metsulfuron methyl : May cause eye irritation. May cause:, Tearing, redness, or discomfort..
Carcinogenicity
1/7
Safety Data Sheet
Ally® Herbicide
Version 1.0
None of the components present in this material at concentrations equal to or greater than 0.1% are listed by IARC,
NTP, or OSHA, as a carcinogen.
Other Ingredients 40 %
Eye contact : Hold eye open and rinse slowly and gently with water for 15-20 minutes.
Remove contact lenses, if present, after the first 5 minutes, then continue
rinsing eye. Call a poison control center or doctor for treatment advice.
General advice : Have the product container or label with you when calling a poison control
center or doctor, or going for treatment.
See Section 1 for emergency phone numbers. See Label for Additional
Precautions and Directions for Use.
2/7
Safety Data Sheet
Ally® Herbicide
Version 1.0
Under severe dusting conditions, this material may form explosive mixtures in
air.
Suitable extinguishing media : Water spray, Foam, Dry chemical, Carbon dioxide (CO2)
Firefighting Instructions : In the event of fire, wear self-contained breathing apparatus. Wear full
protective equipment.
(on small fires) If area is heavily exposed to fire and if conditions permit, let
fire burn itself out since water may increase the area contaminated. Cool
containers/tanks with water spray.
Safeguards (Personnel) : Evacuate personnel, thoroughly ventilate area, use self-contained breathing
apparatus. Wear personal protective equipment.
Spill Cleanup : Prevent further leakage or spillage. Dike spill. Sweep up and shovel into
suitable containers for disposal.
Accidental Release Measures : Prevent material from entering sewers, waterways, or low areas.
Follow applicable Federal, State/Provincial and Local laws/regulations.
Handling (Physical Aspects) : Keep away from heat and sources of ignition. Dust may form explosive
mixture in air.
3/7
Safety Data Sheet
Ally® Herbicide
Version 1.0
Storage : Do not contaminate water, other pesticides, fertilizer, food or feed in storage.
Store in original container. Store in a cool, dry place. Keep out of the reach of
children.
Exposure Guidelines
Exposure Limit Values
No data available
Metsulfuron methyl
Inhalation 4 h LC50 : > 5.3 mg/l , Rat
Oral
Rat
Dermal
Rabbit
Skin irritation
5/7
Safety Data Sheet
Ally® Herbicide
Version 1.0
Additional ecological information : Environmental Hazards: Do not apply directly to water, or to areas
where surface water is present, or to intertidal areas below the mean
high water mark. Do not contaminate water when cleaning equipment
or disposing of equipment washwaters or rinsate.