3.5 PSC12 MOUNTING AND BATTERY CONNECTION .

OVERVIEW :
∂ The Model PSC-12 from Siemens Industry, is a high cur-
rent power supply that provides the FireFinder-XLS
system with primary regulated 24VDC. It is rated at 12A
and has a built-in charger that is capable of charging up to
100AH batteries.

∂ PSC12 will work both in 230V and 110Vac

∂ PTB: Power Termination board.

∂ Power Termination Board filters the power from the in-

coming AC mains and distributes it to the PSC-12 power
supply..

WHERE TO FIX:
PSC12
∂ The PSC-12 mounts at the back of the enclosure of the
FireFinder-XLS system and occupies one location on the
studs in the backbox.

∂ The PSC-12 can occupy any position in the backbox or

on the mounting plate, but it should be installed in the row
and position that is located directly above the PTB to which it
is connected.

PTB:
∂ PTB will be fixed at the bottom of the PSC12 and will be
fixed inside the backbox.

Proprietary Information of Siemens Building Technologies IN BT SSP OPS TCG, July’17

All right reserved
 HOW TO FIX:
Required tools:
∂ Star screw driver and flat screw driver.

∂ Screws will be provided along with PSU.

∂ Powersupply will be heavy. Hence handle with care.

Fixing:
∂ The PSC-12 mounts at the back of the enclosure of the
FireFinder-XLS system and occupies one location on the
studs in the backbox.

PTB:

REQUIRED TOOLS:
∂ Box spanner. (9x10)

Fixing:
∂ PTB will be fixed below to PSU.

∂ Using box spanner screw the Four terminal.

Proprietary Information of Siemens Building Technologies IN BT SSP OPS TCG, July’17

All right reserved
 WIRING:
∂ The main AC power line must be turned OFF.

∂ Panel should be powered by certified commissioning en-

gineer. Till then panel can be off.

Note:
∂ Always Line should be on rght side of the socket.

∂ L N : 230V
L E : 230V
N E : <3V.

∂ Also the same votage should be measured when UPS runs

in battery mode.

Proprietary Information of Siemens Building Technologies IN BT SSP OPS TCG, July’17

All right reserved