Professional Documents
Culture Documents
Tank Baffles Design Calc
Tank Baffles Design Calc
Version 1.0
by Daniel de la Torre
Process Engineer
Intro This template contains a series of calculation sheets to assist you in calculating the baffles dimens
Please note that if agitator is off-centered normally is not needed to install the baffles, as the effe
The main objectives are to provide a reference about baffles dimension and installation distances
Setup 1 There are 2 worksheets, one with Metric units (SI) and one with Imperial units
2 Individual worksheets are protected against inadvertant data entry. Unlocked cells appears with
3 To change any other cells, unlock the workbook (from the Tools/Protection pull-down menu)
4 The baffle size is calculated according to 2 methods, the one called cal 1 using the viscosity of the
See Calculations point for more details
Calculation 1
alc
lculating the baffles dimension and position in a tank, when the tank has a central agitator
nstall the baffles, as the effect is relatively similar, with a more clean installation
n and installation distances details a compare results between more than one calculation method
nlocked cells appears with blue text color. No password needed to unlock
1 using the viscosity of the product, while the one called calc 2 not using it
Calculation 2
Calc sheet developed by Daniel de la Torre Comments to: DeLaTorreY.Eng@gmail.com
Project name Xxxxxxxxxxx
Project or Process Engineer Xxxxxxxxxxx
Project Manager Xxxxxxxxxxx
Description Xxxxxxxxxxx
Product Xxxxxxxxxxx
Case Xxxxxxxxxxx
Size of
Size of Baffle Offset from Reference: Impeler Beginning of End of Baffle
Diameter, Height, Baffle acc.
DESCRIPTION Viscosity Ratio acc. calc 1 the Shell - Min impeller & Max impeller diameter - baffle from from top of
Dt H calc 2 -
w/6 Diam Diam d bottom - d/2 Tank - H *10%
w/12
mm mm cP - mm mm mm mm mm mm mm mm
Process tank number 1 2600 3000 25 0.0805 209 217 36 780 1560 1200 600 300
Process tank number 2
Process tank number 3
Process tank number 4
Calc sheet developed by Daniel de la Torre Comments to: DeLaTorreY.Eng@gmail.com
Project name Xxxxxxxxxxx
Project or Process Engineer Xxxxxxxxxxx
Project Manager Xxxxxxxxxxx
Description Xxxxxxxxxxx
Product Xxxxxxxxxxx
Case Xxxxxxxxxxx
inch inch cP - inch inch inch inch inch inch inch inch
Process tank number 1 102.0 118.0 25 0.0805 8.2 8.5 1.4 30.6 61.2 47.2 23.6 11.8
Process tank number 2
Process tank number 3
Process tank number 4