Professional Documents
Culture Documents
BMM1213 Statics Assignment Co1 (Chapter 2,3,4)
BMM1213 Statics Assignment Co1 (Chapter 2,3,4)
COURSE : STATICS
INSTRUCTIONS TO CANDIDATES:
1. This examination paper consists of THREE (3) questions. Answer ALL questions.
2. All answers to a new question should starts on a new page.
3. All calculations and assumptions must be clearly stated.
4. Candidates are not allowed to bring any materials other than those allowed by the
invigilator into the examination room.
EXAMINATION REQUIREMENTS:
NONE
APPENDIX:
NONE
This examination paper consists of SEVEN (7) printed pages including the front page.
CONFIDENTIAL 2223I/BMM1213
a) Figure 1 shows three cables with force F1, F2 and F3 attached to the metal rod on the wall.
The magnitude of force in cables F1 and F2 are 12 kN and 10 kN respectievely. Assume all
cables are in tension and are in equilibrium conditions, determine the magnitude of force
F3 and its coordinate direction angles α3, β3 and γ3 if the resultant force is FR = {9j} kN.
[16 Marks]
[CO1, PO1, C4]
Figure 1
2
CONFIDENTIAL 2223I/BMM1213
b) Figure 2 shows three metal rods with force F1, F2 and F3 attached to the ball-and-socket
joint on the ground. The magnitude of force in rods F1 and F2 are 10 kN and 8 kN
respectievely. Assume all rods are in equilibrium conditions, determine the magnitude and
coordinate direction angles of the resultant force if magnitude of force F3 is F3 = 9 kN and
θ = 30 ̊ and ϕ = 45 ̊ respectively.
[19 Marks]
[CO1, PO1, C4]
Figure 2
3
CONFIDENTIAL 2223I/BMM1213
Figure 3 shows the hot air balloon being secured by three ropes AB, AC & AD on the ground
before taking off for the rides over the skies of Cappadocia, Turkey.
a) Determine the tension of ropes AB, AC & AD when the burners inject a flame, heating
the air within the balloon envelope, giving a vertical force of 1.8 kN and elevating the
balloon to the height H =17 m from the ground. Assume all ropes are in tension and are
in equilibrium conditions.
[24 Marks]
[CO1, PO1, C4]
b) The burners that inject a flame into the balloon envelope are fueled by propane, a
liquefied gas stored in pressure vessels. After 3 hours of securing from the ground, the
propane slowly runs out of gas that leaves the balloon with the vertical force of 800 N.
If all ropes AB, AC & AD are in equilibrium, suggest the new elevation H from the
ground given that the angle θ between rope AC and AD within 50° < 𝜃𝜃 < 60°.
[11 Marks]
[CO1, PO1, C5]
4
CONFIDENTIAL 2223I/BMM1213
Figure 3
5
CONFIDENTIAL 2223I/BMM1213
a) The townline exerts a force of P = 4 kN at the end of the 20 m long crane boom as
shown in Figure 4. If the distance from crane boom at point O to location A is
x = 25 m, calculate the moment and the crane boom angle θ so that it makes the
maximum moment about point O.
[10 Marks]
[CO1, PO1, C4]
Figure 4
[10 Marks]
[CO1, PO1, C4]
6
CONFIDENTIAL 2223I/BMM1213
Figure 5
c) The tool Figure 6 is used to shut off gas valves that are difficult to access. If the force
F is applied to the handle in the direction shown, determine the magnitude of the
moment created about the z-axis of the valve.
[10 Marks]
[CO1, PO1, C4]
Figure 6