Professional Documents
Culture Documents
How To Replace The Front Brake Pads of Disc Brake On Peugeot 407
How To Replace The Front Brake Pads of Disc Brake On Peugeot 407
2 3
Place wedge blocks under the rear wheels. Loosen wheel bolts on standing on the ground
vehicle
4 5
www.autodoc.co.uk 1–6
How to replace the front brake
pads of disc brake on Peugeot 407
6.1 6.2
7 8
Disconnect the wiring from the brake pad wear Remove the brake caliper.
indicator.
9.1
Tie the caliper to the suspension or to the body Remove the brake pads.
with a wire without disconnecting from the brake
hose to prevent depressurization of the brake
system.
www.autodoc.co.uk 2–6
How to replace the front brake
pads of disc brake on Peugeot 407
9.2
AutoDoc recommends:
Replace all four pads, if even one of them has got oil or
grease. Remember that there is no way to completely clean
a pad.
Before installing the pads, make sure that the guide pins
move freely in the caliper bracket, and make sure the guide
pin rubber dust caps are not damaged. If the move is difficult,
grease the caliper guide pins with a lubricant.
10 11
12.1
AutoDoc recommends:
Remove the expansion tank cap and check the brake fluid
level in it. When the piston is pressed into the wheel cylinder,
brake fluid is pressed out of the cylinder into the tank. If
necessary, pump out the fluid.
www.autodoc.co.uk 3–6
How to replace the front brake
pads of disc brake on Peugeot 407
12.2
AutoDoc recommends:
Make sure the pads are installed with linings facing the disc.
13.1 13.2
14 15
www.autodoc.co.uk 4–6
How to replace the front brake
pads of disc brake on Peugeot 407
16 17
Install the wheel. Lower the car and working in a cross order,
tighten the wheel bolts (torque 90 N·m).
18
AutoDoc recommends:
Check the brake fluid level in the expansion tank
Slow down smoothly for first 150-200 km after the brake
and refill if necessary. pads replacement. Avoid unneccessary and sharp braking to
a stop.
Video tutorials
Watch our detailed video guides about your Peugeot 407
repair on our youtube channel. Watch video guides.
AutoDoc online
Highest quality brake pads for your car Peugeot 407 are
We hope that this information available on AutoDoc. Go to the website.
www.autodoc.co.uk 5–6
How to replace the front brake
pads of disc brake on Peugeot 407
Disclaimer:
The document contains only general recommendations that may be useful for you when you perform repair or replacement works. AutoDoc
shall not be liable for any loss, injury, damage of property, acquired in the repair or replacement process due to incorrect usage or
misinterpretation of the provided information.
AutoDoc shall not be liable for any possible mistakes and uncertainties in this guide. The information provided is for informative purposes only
and cannot replace advice from specialists.
AutoDoc shall not be liable for incorrect or hazardous usage of equipment, tools and car parts. AutoDoc strongly recommends to be careful
and observe the safety rules when performing repair or replacement works. Remember: usage of low quality auto parts does not guarantee
you the appropriate level of road safety.
www.autodoc.co.uk 6–6