Professional Documents
Culture Documents
Scrub Cap For Men and Women
Scrub Cap For Men and Women
com
www.myhallcloset.com email: nath@myhallcloset.com
Note: This pattern is for YOUR personal instruction use only. YOU CAN make caps using my
pattern and YOU CAN sell the actual hats that YOU make and YOU CAN donate the caps.
Pattern is NOT for resale in any way. You are not granted permission to share in any way online or
otherwise, in whole or in part for free or for sale. Do not to rewrite the instructions and sell them
as though they belong to you. I trust that you won’t do that. If you do, that is called Intellectual
Property Rights Infringement and is illegal.
Cut a strip 2” wide and Fold fabric over 15” on cross On the extra fabric, fold
the width of the fabric. grain. Not edge to edge. Cut over so you can cut the
along the outer edges. This fabric Crown on the fold.
was 44”. Used 1/3 of a yard.
Mark the dot in the dip of Cut a tiny notch in the center of Fold the long strip in half
the on “B” and at the end the top of the Crown and at the and press.
of the Crown. Use a water fold on the back of “A”. These will
erasable pen or pencil. be matched during stitching.
Turn the pointed part under. The This is how it should look.
Clip a TINY little corner off
folded under part (arrow) will need
like in the photo.
to be caught in the stitching , when
you stitch.
Stitch both from the angled end This is how it should look.
Measure in 4”. Mark with a
to the 4” mark. Back stitch at
pin or a pen (water erasable).
the beginning and the end.
Use safety pin on the cut end of the At the 4” opening, remove the Feel to make sure that you a
tie. Work it through the opening safety pin and carefully pull the about ¼” of the tie past the 4”
starting at the angled end. tie back to the 4” mark. mark. Pin the tie in place.
At the 4” mark, stitch across the tie. Stitch the length of the turned This is how it should look.
Forward, back stitch and forward. under part. Pivot at the 4” mark.
With the needle down, pivot the Stitch Forward, back stitch and
fabric. forward.
Before I stitch, I release that last Using a ¼” seam, stitch the 2 pieces As you get to the end, be
pin. But you don’t have to. together. For a smaller person, use ½” careful to match the edges and
seam. Adjust fullness as you stitch. not catch the band fabric in the
stitching.
For guy or gals. For Long hair or short hair. Close the back up or open it for a ponytail.