Professional Documents
Culture Documents
7003 Drum
7003 Drum
4-34
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
3 Remove two screws (a)(M4x8) and open the front middle cover (b).
4 Lock the developer waste exit that hasbeen released. (Refer P.2-15)
5 Remove the screw (c) and open the connector cover (d).
4-35
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
9 Release the lock by pushing the fixing levers (b) at the right and left of inner unit (a).
10 Remove the inner unit (a).
11 Close the toner supply shutter (c) of the inner unit (a).
Be sure to unlock the developer waste exit after the inner unit (a) has been installed.
4-36
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
4-37
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
2 Close the toner supply shutter (b) of the developer unit (a).
4-38
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
5 Release the lock lever (b) at lower side of the developer unit (a) and then pull out the
developer unit (a).
6 Check or replace the developer unit (a) and then reattach the parts in the original
position.
7 Execute the following procedures when replacing the developer unit to the new unit (a).
1 Execute maintenance mode U140 (AC calibration). (Refer P.6-112)
When a new development unit is installed, the developer roller protective sheet (a) must be removed.
Shake from side to side five times or more before attaching the developer unit (a).
4-39
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
5~
4-40
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
4-41
[CONFIDENTIAL]
Maintenance > Maintenance parts replacement procedures
7 Check or replace the drum unit (a) and then reattach the parts in the original position.
8 Execute the following procedures when replacing the drum unit to the new unit.
1 Execute maintenance mode U119 (Drum setup). (Refer P.6-101)
2 Pull out the main charger roller unit (a) by picking and releasing the MC lock lever (b).
3 Check or replace the main charger roller unit (a) and then reattach the parts in the
original position.
When reattaching the main charger roller unit (a), hook the hook (c) firmly by operating the MC lock lever (b) after
inserting the main charger roller unit (a) until click.
4-42