Professional Documents
Culture Documents
1 - Connectors of PSXXX-270
1 - Connectors of PSXXX-270
China
Connectors of PSXXX-270
Seal and protect the unoccupied M12 sockets of the sensor with M12 screw plugs.
In this way IP67 protection is reached for harsh environmental conditions, even if
no connector is attached.
1. Remove the protection plastic cap.
2. Align marks at the retainer ring and the socket.
3. Push the connector into the socket.
4. Turn the retainer ring to secure the connection.
WARNING
Protection class IP67 is only reached by occupied connector.
Before attaching the connector,
connector make sure the sealing rubber ring in the sockets
is in place.
Be sure to protect unoccupied connection sockets with sealing protection caps.
WARNING
Power supply
Without heater: 24 Volt, 0.30 Ampere, 8 Watt
With optional internal heater: 24 Volt, 1.25 Ampere, 30 Watt
ATTENTION
Reply outputs OUT1 and OUT2 are options and not available for all PS
PSXXX-270
Laser Sensors.
WARNING
Protection class IP67 is only reached by occupied connector.
Before attaching the connector,
connector make sure the sealing rubber ring in the sockets
is in place.
Be sure to protect unoccupied connection sockets with sealing protection caps.
Measurement Board (MPU) DSUB9 male DTE pin layout (socket view)
WARNING
Protection class IP67 is only reached by occupied connector.
Before attaching the connector,
connector make sure the sealing rubber ring in the sockets
is in place.
Be sure to protect unoccupied connection sockets with sealing protection caps.