Professional Documents
Culture Documents
Ericsson 2G Commangs
Ericsson 2G Commangs
Ericsson 2G Commangs
5. rxasp:mo=rxotg-105;
This command is useful to see the active alarms on the site whose TG value
is 105. There are various alarms in the site.
Some of the alarms are permanent fault, oml fault, BTS INT affected and so on.
Check also: Ericsson bts wcdma/3g commands
6. rxcdp:mo=rxotg-105;
By using this command you can view the radio receiver configuration data
to check the particular sector is working, or the site is just about to come.
There are three states. 1. BLOCKED
2. CONFIG
3. UNUSED
If the command output window shows BLOCKED then the site is down or not working.
If the command output window shows CONFIG then the site or the particular sector
hardware is working.
If the command output window shows UNUSED the site is about to working in few
seconds or a minute.
7. rxmfp:mo=rxotg-26,subord,faulty;
It is used to know the fault code for the hardware in the rbs bts. Fault
code examples are 2A-12 , 1A-19, 2A-19 and so on. There is a software decoder which
decodes these fault code and provides the fault details and solution for the
faults.
I have explained in short some basic commands of WINFIOL for the operation and
maintenance of ERICSSON 2G BTS.