Professional Documents
Culture Documents
A&ECUD Question Paper
A&ECUD Question Paper
THEORY TEST
NAME: ___________________________________________________________
BATCH: _________________________________________________________
DATE: ___________________________________________________________
Note:
its is mandatory to answer all questions.
50 questions each 1 marks.
Q.1 : which is the most common ECU brand used in modern vehicles ?
Magneti Marelli
Bosch
DENSO
Delphi
Petrol
Diesel
CNG
None of the above
Resistor
Thermistor
Transistor
Transformer
Transistor
Diode
Capacitor
None of the above
To Store voltage
To Store current
To Resist current
To Resist capacitance
To store voltage
To store current
To resist current
To resist capacitance
NPN junction
PNP junction
PPN junction
PNN junction
Q. 12 : in which holes of the multimeter probes should be placed for testing ECU ?
Ktag
Launch Scanner
Xtool scanner
UPA-USB programmer
Cloning transponder
Generating transponder
Remote cloning
All of the above
432 Ohms
43.2 Ohms
4.3 kOhms
4.32 kOhms
330 F
330
33
3.3 F
No polarity
Marked side is positive
Unmarked side is negative
Marked side is negative
No polarity
Marked side is negative
Unmarked side is negative
Marked side is positive
SMD blower
Soldering
Both of the above
None of the above
Q. 29 : What is the Voltage range for on table power supply testing of ECU’s ?
200V
2V
20V
200mV
No polarity
Marked side is negative
Unmarked side is negative
Marked side is positive
!988
1996
1993
1999
12.3V
12.5V
12.6V
12.4V
5V
2.5V
12V
1.5V
Q.34 : What is the purpose of calibration function of the car scanner in modern vehicles ?
To calibrate sensor
To calibrate motor
To calibrate relay
To calibrate infotainment system
Check sensors
Check actuators
Connect scanner
Connect battery tester
Q. 41 : What is the first step of root cause analysis with car scanner ?
Read DTC
Read data stream
Erase DTC
Actuation test
Q. 42 : What is the basic requirement for resetting the oil maintenance with scanner ?
No service light
No DTC stored in engine
No DTC stored in BCM
No check engine light
Q. 43 : Explain the process of programming TC1767 microcontroller chip using KTM bench ?
Q. 44 : precautions for using KTM bench ?
Q. 46 : Explain the procedure for reading and writing data using vehicle menu..?
Q. 47 : What is the most common component which fails on PCB and Why ?
Q. 48 : Write Down the pre-diagnostic functions of a car scanner.