Professional Documents
Culture Documents
Desert Diamond Crochet - 048 - Pink Panther Hat Infant To Adults (C) (NEW)
Desert Diamond Crochet - 048 - Pink Panther Hat Infant To Adults (C) (NEW)
“Panther Hat”
Infant to Adults
Page 1 of 24
Materials Needed:
Red Heart Super Saver
1 skein Pretty N’ Pink
Small amounts of Lt. Raspberry, White, Black, Corneal, Burgundy
Yarn Needle
F, H hook (or size needed to obtain gauge)
Stitches:
CH: chain
SC: single crochet
SC DEC: single crochet decrease
SLST: slip stitch
Rnd 1: With Pretty N’ Pink and H hook, CH 2, 6 SC in 2nd CH from hook, do not
join. Use a stitch marker if needed. (6 SC)
Rnd 3: *1 SC in next SC, 2 SC in next SC*, repeat from * to * around. (18 SC)
Page 2 of 24
Rnd 8: *1 SC in each of the next 6 SC, 2 SC in next SC*, repeat from * to *
around. (48 SC)
Page 3 of 24
18” – 20” (6 Month - Toddler)
It is important to get a head measurement of anyone over the age of 12 months for best sizing
Rnd 10: *1 SC in each of the next 8 SC, 2 SC in next SC*, repeat from * to *
around. (60 SC)
Rnd 10: *1 SC in each of the next 8 SC, 2 SC in next SC*, repeat from * to *
around. (60 SC)
Rnd 11: *1 SC in each of the next 9 SC, 2 SC in next SC*, repeat from * to *
around. (66 SC)
For heads larger than 22”, perform one more increase round.
Page 4 of 24
Earflaps
Lay hat flat on hard surface with the tie off in the center of the back of the hat.
Count 3 stitches in from the sides of each side and place a marker. If you don’t
have stitch markers, you can use a piece of yarn.
Left earflap
With right side facing, opening at the top, attach hat color to the spot at the left side
stitch marker.
Row 1:
14” – 16” & 16” – 18” CH1, 8 SC, CH 1, Turn
18” – 20” CH 1, 10 SC, CH 1, Turn
20” – 22” CH 1, 12 SC, CH 1, Turn
Page 5 of 24
Right earflap
With right side facing, opening at the top, count to the right the stitch marker the
number of stitches required for the size you are making and attach yarn.
Row 1:
14” – 16” & 16” – 18” CH1, 8 SC, CH 1, Turn
18” – 20” CH 1, 10 SC, CH 1, Turn
20” – 22” CH 1, 12 SC, CH 1, Turn
TRIM (optional)
Attach trim color (Lt. Raspberry Pink) to the back of the hat in the same stitch
where hat was fastened off. CH 1, SC in each stitch and row end around the hat.
Do 3 SC in the tip of each earflap if earflaps were created. SLST to join, Fasten
Off.
Page 6 of 24
OPTIONAL FACE
SNOUT
You may want to consider dropping to an “F” hook for 14” – 16” hat if the snout is coming out too large.
Rnd 1: With White and “H” hook, CH 2, 6 SC in 2nd CH from hook. Do not join.
(6 SC)
Rnd 3: *1 SC in next SC, 2 SC in next SC*, repeat from * to * around. (18 SC)
Rnd 5: Working in Back Loops only, Attach Pretty n’ Pink to any SC with a SC
and SC in each SC around (24 SC)
Rnd 10: SC in each SC around, SLST to join, Fasten off leaving a tail to sew
with. (24 SC)
MOUTH
Rnd 1: With White and “H” hook, CH 2, 6 SC in 2nd CH from hook. Do not join. (6 SC)
Rnd 3: *1 SC in next SC, 2 SC in next SC*. Repeat from * to * around, SLST to join, fasten
off. (18 SC)
Rnd 4: Attach Pretty n’ Pink with a SC in any stitch and SC in each SC around. (18 SC)
Rnd 7: 1 SC in each SC around, SLST to join. Fasten Off leaving a tail to sew with. (18 SC)
Fold the piece flat and whip stitch the end closed with tail.
Page 7 of 24
TONGUE
Rnd 1: With Lt. Raspberry and “H” hook, CH 2, 6 SC in 2nd CH from hook, CH
1, Turn. (6 SC)
Rnd 3: *2 SC in first SC, 1 SC in next 2 SC*, repeat from * to * across. (12 SC)
EYES (make 2)
Rnd 1: With Cornmeal and “H’ hook, CH 2, 6 SC in 2nd CH from hook. (6 SC)
Page 8 of 24
PUPILS (make 2)
Rnd 1: With Black and “F” hook, CH 2, 6 SC in 2nd CH from hook, SLST to join,
Fasten off leaving a tail for sewing. (6 SC)
NOSE STRIP
Row 1: With “F” hook and Lt. Raspberry, CH 2, SC in 2nd CH from hook, CH 1
turn (1 SC)
Row 11: SC in each stitch around, SLST to join, fasten off leaving a tail for
sewing.
NOSE
Row 1: With “F” hook and Burgundy, CH 2, SC in 2nd CH from hook, CH 1 turn
(1 SC)
Row 5: SC in each stitch around, SLST to join, fasten off leaving a tail for sewing.
Page 9 of 24
EYE BROWS – make 2
Round 1: With Black and “H” hook, CH 8, SLST in 2nd CH from hook and in
next 3 CHs, Fasten off leaving a tail to sew with.
Rnd 1: With White and “H” hook, CH 2, 6 SC in 2nd CH from hook (6 SC)
Rnd 1: With Pretty n’ Pink and “H” hook, CH 2, 6 SC in 2nd CH from hook (6 SC)
Rnd 4: Pick up inner ear. Hold inner ear with right side facing out to the outer
ear. Working through bother pieces, *1 SC in next 2 SC, 2 SC in next SC*, repeat
from * to * around (24 SC)
Rnd 5: 1 SC in each SC around, SLST to join, fasten off leaving tail for sewing
(24 SC)
Page 10 of 24
ASSEMBLY
1. Find the center of the front of the hat and mark it. Stuff the snout and sew it
to the front of the hat 2 rows up from the trim round. This leaves room to
sew on the mouth piece.
Page 11 of 24
3. Sew the mouth piece centered on the hat under the snout
Page 12 of 24
4. Sew the pupils to the Eyes and then sew the eyes onto the hat on either side
of the snout in desired position. You can add a white mark to the pupil if
desired.
Page 13 of 24
5. Sew the Nose Strip to the top of the snout. Line the wide end up with the
white section of the snout and center the strip with the skinny end between
the eyes.
6. Sew the nose with the wide side to the top of the snout aligned with the nose
strip. Thin point should meet center of the white snout area.
Page 14 of 24
7. Sew the eyebrows on above the eyes. Sew chain side down so that the
eyebrow stands up.
9. With Lt. Raspberry Pink, make three dots on front of snout on either side
Page 15 of 24
10. With black, cut 4 – 4” strands. Using two strands for each side, latch hook
two strands to either side of snout to create the whiskers. Trim do desired
length.
Page 16 of 24
TIES
Use 4 strands of each color for each earflap. Fold the strands in half forming a
loop at the top.
Page 17 of 24
Slip the crochet hook into the bottom of the earflap. Pull the loop through the
earflap.
Take the strands and pull them through the loop and pull tight to secure.
Page 18 of 24
Divide the strands into 4 equal sections of 4 strands each alternating colors and
braid.
You will braid the strands just like a three way braid. You just have a 4 th group.
Start with the far right color.
Page 19 of 24
In this example the white group on the far right. Bring the white group over the
top of the red group to its left.
Next take the second white group and bring it over the first white group
Page 20 of 24
Finally, bring the red group on the far left under the first white group which is now
in position 3.
Doing the four way braid with alternating colors generates the striping pattern. If
you do not want the striping pattern then divide per your liking and braid normally.
Pull the first group tight and then repeat the steps. This time it is the red group on
the far right. Bring it over the white group to the left of it.
Page 21 of 24
Next bring the second red group in 3rd position over the red group in second
position
Then to finish off this row, take the white group in 4th position and bring it under
the red group in 3rd position and tighten up.
Page 22 of 24
Repeat the over, under, over, under technique all the way down the tie. When you
get to the bottom of the tie, make a slip knot to secure the braid.
Repeat for the second earflap. Compare the braids to each other and adjust slip
knots as needed and trim ends even.
Page 23 of 24
*****************************************************************************
You can sell any items you make from using my patterns, but you are responsible for your finished items.
Please do not recopy, resell, rewrite or redistribute this pattern as your own or in any other form.
If you plan on selling your items online, please coordinate with me on price so that we are competitive and not
stepping on each other’s stores.
Please include with all your “Sale” items both online and off, a comment that this pattern was designed by Rebecca
Goldsmith of Desert Diamond Crochet and provide a link back to my Etsy store:
http://www.etsy.com/shop/desertdiamond
www.etsy.com/shop/desertdiamond
Page 24 of 24