Professional Documents
Culture Documents
ADC V515 Installation Guide
ADC V515 Installation Guide
Wi-Fi Camera
Installation Guide
ADC-V515
Pre-installation checklist
• ADC-V515 camera (included)
1
In the box Installation
• ADC-V515 camera Connect the camera to the Wi-Fi network
• Mounting bracket
• Power adapter AP mode
• Installation guide
• Wall anchors & screws (x2) To ensure sufficient Wi-Fi signal, complete these steps
with the camera near its final location but prior
to mounting.
❶ Camera lens
❺ ❷ The camera’s LED will begin to blink white.
If the LED is not white after two minutes, hold down the
❷ Infrared light
❶ Reset button and release when the LED begins to
blink white (about 6 seconds).
❸ Status light
❷ ❸ On an Internet enabled device, connect to the Wi-Fi
❹ Ambient light sensor
❸ network ADC-V515 (XX:XX:XX) where XX:XX:XX is the
last six characters of the ADC-V515’s MAC address,
❺ Microphone which is located on the camera or on the packaging.
❹ Base
❹ ❺ Connect the camera to the Wi-Fi network
❶ Rubber pad ❷ ❶ Connect the camera’s AC power adapter and plug it into
a non-switched outlet.
❷ Mounting recess
❸ ❷ Hold down the Reset button on the back of the
❸ Speaker
❹ camera and release when the LED begins to blink blue
(about 3 seconds).
❹ SD card door
continued
2 3
❸ Activate the WPS mode on the router. The camera will ❹ Follow the on-screen instructions to finish
begin to connect to the Wi-Fi network. The LED will be adding the camera.
solid green when the connection is complete.
You can now power down the camera and install it in its
❹ See the Add the device to an account section to final location using the included hardware. You may
complete the installation. configure camera settings from the Customer Website.
MobileTech Installation Blinking blue
WPS mode
❶ Log in to MobileTech.
continued
4 5
Troubleshooting Notices
• If you have issues connecting the camera to the account, Federal Communication Commission
power cycle the camera and try again. interference statement
• If issues persist, press and hold the Reset button This equipment has been tested and found to comply with the limits for a
located on the bottom of the camera until the LED is Class B digital device, pursuant to part 15 of the FCC Rules. These limits are
blinking green and red (about 15 seconds), then release designed to provide reasonable protection against harmful interference in a
the button. The camera will reboot with factory residential installation. This equipment generates, uses and can radiate radio
default settings. frequency energy and, if not installed and used in accordance with the
instructions, may cause harmful interference to radio communications.
If the camera was previously installed to an However, there is no guarantee that interference will not occur in a
Alarm.com account, it will need to be deleted particular installation. If this equipment does cause harmful interference to
before it can be installed again. radio or television reception, which can be determined by turning the equipment
off and on, the user is encouraged to try to correct the interference by one or
more of the following measures:
Questions?
Visit answers.alarm.com • Reorient or relocate the receiving antenna.
or contact your service provider.
• Increase the separation between the equipment and receiver.
which the receiver is connected.
IC statement
• This device must accept any interference, including interference that may
cause undesired operation of the device.
6 7
Notes
8281 Greensboro Drive
200518
Suite 100 © 2020 Alarm.com.
Tysons, VA 22102 All rights reserved.