Professional Documents
Culture Documents
Paperless Graphic Recorders: Specification Sheet
Paperless Graphic Recorders: Specification Sheet
MODEL
Paperless Graphic Recorders
Specification Sheet
Input board
General
Input types: dc Volts, dc millivolts,dc milliamps (with
shunt), Thermocouple, 2/3-wire RTD
Contact closure (not Channel 1) >60 ms
Input type mix: Freely configurable.
Max. number of inputs: 6 per board
A/D conversion method: >16 bits, 2nd order delta sigma
Input ranges: See Table1 and Table 2
Termination: Edge connector / terminal block
Noise rejection (48 to 62Hz): Common mode: >140dB (channel to
channel and channel to ground).
Series mode: >60dB
Max common mode voltage: 250 Volts continuous
Max series mode voltage: 45mV at lowest range;
23.74 Volts peak at highest range
DC Input ranges
Transmitter PSU
Shunt: Externally mounted resistor modules Number of outputs: Three, isolated
Additional error due to shunt: 0.1% of input Output voltage: 25V nominal
Additional error due to Maximum current: 20mA per output
attenuator: 0.2% of input Isolation (dc to
Performance: See Table 1 65Hz BS61010): Installation category II;
Pollution degree 2
Typical error Maximum error Worst case Channel to channel: 100V RMS or DC (double insulation)
(instrument (instrument temp Channel to ground: 100V RMS or dc (basic insulation)
Low High at 20°C) at 20°C) Performance Fuse (20mm Type T)
Range Range Resolution Range Range Input per °C
Supply voltage = 110/120V ac: 100mA
-38mV 38mV 1.4μV 0.013% I/P + 0.031% 0.030% I/P + 0.052% 25ppm
-150mV 150mV 5.5μV 0.013% I/P + 0.028% 0.029% I/P + 0.039% 25ppm
-1V 1V 37μV 0.013% I/P + 0.024% 0.029% I/P + 0.029% 25ppm Relay output board
-20V 20V 720μV 0.075% I/P + 0.027% 0.393% I/P + 0.033% 388ppm General
Table 1 Voltage ranges - accuracy and resolution Maximum number of
relay boards: 1
Typical error Maximum error Worst case Number of relays per board: 3 per C/O
(instrument (instrument temp Estimated mechanical life: 30,000,000 operations
Low High at 20°C) at 20°C) Performance Update rate: See ‘Update rates’ in ‘Recorder
Range Range Resolution Range Range Input per °C Specification’ above
0Ω 150Ω 5mΩ 0.027% I/P +0.034% 0.037% I/P + 0.077% 30ppm AC load ratings
0Ω 600Ω 22mΩ 0.027% I/P +0.035% 0.037% I/P + 0.057% 30ppm
Derating
0Ω 5KΩ 148mΩ 0.030% I/P + 0.034% 0.040% I/P + 0.041% 30ppm The figures give below are for resistive loads. for reactive or inductive loads,
Table 2 Resistance ranges - accuracy and resolution de-rate in accordance with Graph 1, in which:
F1 = Actually measured results on
Thermocouple data representative samples
Temperature scale: ITS 90 F2 = Typical values according to experience
Bias current: 0.05nA Contact life = Resistive contact life x reduction factor
Cold junction types: Off, internal, external, remote Maximum switching power: 500VA
CJ error: 1°C max with inst. at 25°C Maximum contact voltage: 250V providing this does not cause the
CJ rejection ratio: 50:1 minimum maximum switching power (above) to be
Upscale/downscale drive: High, low or none selectable for exceeded
each thermocouple channel Maximum contact current: 2 Amps providing this does not cause the
Additional error: 0.01°C (typ.) if high or low selected
maximum switching power (above) to be
Types and ranges: See Table 3 exceeded
0.7 F1 100
U –200 to +600 DIN43710:1985 0.08°C 0.6
NiMo/NiCo –50 to +1410 ASTM E1751-95 0.06°C 50
0.5 40 inductive
Ni/NiMo 0 to +1406 Ipsen 0.14°C 30 load (L/R
0.4 20 = 20msec)
Platinel 0 to +1370 Engelhard 0.02°C
Pt20%Rh/ 0 to +1888 ASTM E1751-95 0.07°C 0.3 10
1 0.8 0.6 0.4 0.2 0.1 0.2 0.5 1 2 5 20
Pt40%Rh
Power factor (cos f) DC current (Amps)
Table 3 Thermocouple types and ranges Graph 1 Graph 2
24.75mm
Front view Side elevation
246.5mm* Recorder rear termnal panel Long Terminal Cover
144mm 211.5mm
Channel input
144mm
137mm
106.9mm
102mm
Transmitter Power Supply PCB
V+ V– I
35mm R
Access Flap
Black
Black
Black
Red
Red
Red
Panel thickness 6 to 25mm max
Black
Red
Optmum thickness depends on panel material
x
User Terminal Block
137mm
y – + – + – +
)
)
View on underside
– + Other transmitters
* Standard Terminal Cover: 246.5mm
Long Terminal Cover: Closed: 288mm
Transmitter
Open: 415mm
Voltages generated by
various currents for
Panel cut-out R=100Ω and R=250Ω
138mm (+1 –0) x 138mm (+1 –0) (R minimum spec)
= 1.4W ±1% Only one channel shown for clarity
Minimum recommended
inter-unit spacing 100Ω 250Ω
Top/bottom clamps 0mA 0V 0V
Side clamps
4mA 0.4V 1.0V
x = 15mm (0.6 inch) x = 10mm (0.4 inch)
20mA 2.0V 5.0V
y = 10 mm (0.4 inch) y = 15mm (0.6 inch)
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
1,7,13,19, 2,8,14,20, 3,9,15,21, 4,10,16,22, 5,11,17,23, 6,12,18,24,
Channels
25,31,37,43 26,32,38,44 27,33,39,45 28,34,40,46 29,35,41,47 30,36,42,48
V+ V-
V+ V- II V+ V- I V+ V- I V+ V- I V+ V- I V+ V- I
CJC
a˚ b˚
Relay 1 2 3 1 2 3
V+ V- I V+ V- I V+ V- I V+ V- I V+ V- I V+ V- I I V+ V- I
nc
Shunt
com
–20 to +20V dc DC millamps –200 to + 200V dc 3-wire resistance 2-wire resistance Potentiometer Contact closure
Thermocouples thermometer thermometer (Not Chs 1,7,13 etc.)
dc mV
Shunt assembly Attenuator assembly
100W = LA246779UK10 LA244180
250W = LA246779UK25
1 2 3 4 5 6 7 8 9 10 11 12
6100E
6100E Data Acquisition Unit 00 None Installation and safety data sheet
03 3 (1 Option brd) Panel mounting clamps
2 Power Supply
9 Shunt Value Optional Accessories
VH 90-264V ac 110-370V dc 45-65Hz
NOS No shunts Via internet download from
100 100 ohm shunts http://my.eurotherm.co.uk
3 24V Isolated Transmitter Power Supply 250 250 ohm shunts
6000 Tools including Review Lite
(history viewing software and C-
NOITPS None Edit (off line configuration
115TPS 110-120V 3 channel TPS 10 Quantity of 100:1 Attenuators
software).
230TPS 220-240V 3 channel TPS
00 Qty of attenuators Review Full – all the functionallity of
Review Lite plus ability to run as a
4 Memory Card Size service spreadsheet mode and
11 Warranty auto archive the database.
NOMC None
512M 512 Mbyte card (CF) XXXXX Standard
001G 1 Gbyte card (CF) 1WL005 5 year
002G 2 Gbyte card (CF)
004G 4 Gbyte card (CF)
008G 8 Gbyte card (CF) 12 Maths, Totalisers & Counters
MTC00 None
5 USB Memory Stick Size MTC12 12 virtual channels
NOMS None
001GMS 1 Gbyte USB memory stick 13 Custom Label
002G 2 Gbyte USB memory stick
004G 4 Gbyte USB memory stick) XXXXX None
008G 8 Gbyte USB memory stick
14 Special
6 Calibration Certificates
XXXXX None
NOCAL None
STCAL Standard calibration certificate (all channels at 0-1V dc)
CMCAL Custom calibration of each ch as specified on purchase order
15 Bridge
XXXXXX None
BLITE Lite
BFULL Full