WWT - Redução de Torque e Aumento Do Rop Com Protetores

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

WWT Case History - Asia-Pacific - 5732

WWT Non-Rotating Protectors Reduce Torque and Improve ROP

High Torque on Original Wellbore Location: Asia-Pacific


Well Type: Directional
Operator experienced high torque Objective: Torque Reduction
while drilling the 8 ½” hole section. Solution: WWT NRPs
Results: Immediate torque reduction
Before completion of the well, the upon installation of WWT NRPs
BHA became stuck and the
operator was forced to side track to 3000

reach the intended target, using a Actual Torque, ST0 (No NRPs)

near identical well path. Actual Torque, ST1 (NRPs Installed)

3200 Modeled Torque, NRPs Installed

WWT’s NRP Patented Fluid Modeled Torque, No NRPs

Bearing Reduces Torque


300m of WWT NRPs were installed
3400

at the top of the side track which


produced a noticeable torque 3600

reduction compared to torque


while drilling the original wellbore.
Measured Depth (m)

As drilling continued, additional 3800

NRPs were added to the drill string


increasing the torque reduction 4000

seen at the surface. The torque


reduction was estimated by the
customer to be greater than 30% at 4200

TD, keeping the drilling torque


below the make-up torque of the 4400
drill pipe. 15000 20000 25000 30000
Torque (ft-lbs)
35000 40000

In addition Benefits
Additional to the torque reduction experienced, the casing was also protected due to the
to NRPs
NRPs’ ability to eliminate tool joint contact. Side-loads greater than 6,000 lbs/joint were
modeled, which creates a high potential for casing wear. The increased risk of wear, due to
the additional rotating hours for the sidetrack, was greatly reduced through the use of
NRPs.

Cost Savings
The well was successfully completed to TD while staying within rig and drill pipe torque
capabilities. The availability of excess torque at the surface, due to NRPs, allowed the WOB
to be increased which resulted in an improvement in ROP. Casing integrity was also
maintained protecting the high side load areas with NRPs.
WWT Non-Rotating Protectors
www.wwtinternational.com
© 2015 WWT North America Holdings, Inc. All rights reserved. is a registered trademark of WWT North America. Holdings, Inc.

You might also like