Professional Documents
Culture Documents
pc20tk 1 44 29
pc20tk 1 44 29
4-9)
Insert the lead wires from the printed circuit board (large) complete with the components soldered
into the land holes marked with the corresponding symbols of the printed circuit board (small), and
then solder them (3 places of A, B and COM).
4-8 Attaching the connector covers to the printed circuit board (small) (Fig. 4-10)
• Press one black connector cover over the COM
measurement connector until its flange makes
contact with the printed circuit board.
• Similarly press two red connector covers.
Black
Red
Red
connector cover
Fig. 4-10: Attaching the connector covers Fig. 4-9: Wiring the printed circuit board (small)
4-9 Mounting the readout (LCD), the printed circuit boards, and the dial plate
Fig. 4-11
1 Remove the protective transparent film attached to the LCD surface (do not remove the white
film on the rear).
2 Fit the LCD at an angle of about 30 degrees into the area surrounded by the LCD securing pawls
located inside the panel.
3 Once the lower part of the LCD is fit to the pawls, lower the upper part (stepped) to place it
horizontally on the panel.
Caution: The LCD may be broken if excessive force is applied, because it is made of glass.
If the LCD is difficult to mount, hold it with your fingers from its top and bottom
and then slowly snap it into place (see the right illustration).
Stepped side
LCD
1 Remove the
transparent protective
film 2
3
Panel
LCD securing
pawl
Fig. 4-11: Mounting the LCD
27