Professional Documents
Culture Documents
Cop Fs 2011 - A
Cop Fs 2011 - A
Contents
Page
Part A – Introduction
Section 1 – General
Section 2 – Performance Requirements
Section 3 – Definitions
Section 1 – General
Subsection A1 – Use of this Part
Clause A1.1
Clause A1.2
Clause A1.3
Objectives
Functional Statements
and
Performance Requirements
Clause A2.1
To provide for the planning, design and construction of buildings and associated works; to
make provision for the rendering safe of dangerous buildings and land; and to make
provision for matters connected therewith.
Clause A2.2
Life Safety
Property Protection
Commentary
Clause A2.3
Subsection A3 - Compliance
Clause A3.1
Commentary
Subsection A4 - Parts in this Code
Clause A4.1
Clause A4.2
Clause A4.3
Subsection A5 - Change in Use or Bounding Conditions
Clause A5.1
Commentary
Clause A6.1
Commentary
Subsection A7 - Use Classification
Performance Requirement B1
Performance Requirement B2
Performance Requirement B3
Performance Requirement B4
Performance Requirement B5
Performance Requirement B6
Performance Requirement B7
Guidance
Performance Requirement C1
Performance Requirement C2
Performance Requirement C3
Performance Requirement C4
Performance Requirement C5
Performance Requirement C6
Guidance
Subsection A10 – Means of Access
Performance Requirement D1
Guidance
Subsection A11 – Fire Safety Management
Performance Requirement F1
Guidance
Section 3 – Definitions
“Access staircase”
“Alternative exit”
“Balcony approach”
“Basement”
“Bounding Conditions”
“Compartment area”
“Compartment volume”
“Cubical extent”
“Discharge value”
“Element of construction”
“Exit door”
“Exit route”
“Factory”
“Fire barrier”
“Fire compartment”
“Fireman’s lift”
“Flat”
“Ground storey”
“Industrial undertaking”
“Maisonette”
“Non-combustible”
“Notifiable workplace”
“Occupant capacity”
“Protected exit”
“Protected lobby”
“Redevelopment site”
“Refuge floor”
“Required staircase”
“Smoke seal”
“Special hazard”
“Storey”
“Travel distance”
“Use Classification”
“Virgin site”
Diagram A2: Illustration of Exit Route
Exit Route
Point on floor
Travel Distance
Exit Route
Exit Route
Exit Route
Exit Route
Section 1 – General
Section 2 – Provisions of Means of Escape
Section 3 – Special Provisions on Means of Escape for Use
Classification 5a
Section 1 – General
Subsection B1 – Use of this Part
Clause B1.1
Clause B1.2
Clause B1.3
Clause B2.1
Subsection B3 – Application
Clause B3.1
Clause B3.2
Clause B3.3
Section 2 – Provisions of Means of Escape
Subsection B4 – Assessment of Occupant Capacity
Clause B4.1
Occupancy Factor
(usable floor area in
Use
Type of Accommodation m2 per person) or
Classification
otherwise as
specified
Occupancy Factor
(usable floor area in
Use 2
Type of Accommodation m per person) or
Classification
otherwise as
specified
Occupancy Factor
(usable floor area in
Use 2
Type of Accommodation m per person) or
Classification
otherwise as
specified
Subsection B5 – General Requirements of Exit Routes
Clause B5.1
Clause B5.2
Clause B5.3
Clause B5.4
Clause B5.5
Clause B5.6
Clause B5.7
Clause B5.8
Clause B5.9
Clause B5.10
Clause B5.11
Clause B6.1
Subsection B7 – Exits from Rooms and/or Fire Compartments
Clause B7.1
Commentary
Clause B7.2
Clause B7.3
Subsection B8 – Exits from Storeys
Clause B8.1
Clause B8.2
Table B2
Table B2: Minimum number and width of exit doors and exit routes from a room, fire
compartment or storey
Occupant Minimum No. Minimum total width (in Minimum Width (in
Capacity of of exit doors mm) mm) of each
room, fire or exit routes
compartment or
storey (No. of Exit doors Exit routes Exit door Exit route
persons)
Commentary
Subsection B9 – Exits at Ground Storey
Clause B9.1
Clause B9.2
Clause B10.1
Clause B10.2
Clause B10.3
Clause B10.4
Clause B10.5
Clause B10.6
Clause B11.1
Clause B11.2
Clause B11.3
Clause B11.4
Clause B11.5
Clause B11.6
Clause B11.7
Subsection B12 - Discharge Value and Width of Required Staircase
Clause B12.1
Clause B12.2
Clause B12.3
Clause B12.4
Clause B12.5