Do not allow temporary ponding or moisture (Dew, Condensation etc) to remain between coats on any ho- All technical data stated in this Data Sheet are based rizontal surfaces or until the final coating has totally on laboratory tests. Actual measured data may vary cured. Brush or mop surface water away during this due to circumstances beyond our control. time. It is recommended to carry out Adhesion and Compat- LOCAL RESTRICTIONS ibility tests with the Primer prior to application of fol- lowing coats. Note that as a result of specific local regulations the Sikalastic®-560 GCC should not be applied on roofs declared data and recommended uses for this product subject to long-term ponding water especially with may vary from country to country. Consult the local subsequent periods of frost. In cold climatic zones for Product Data Sheet for the exact product data and Roofing structures with a pitch of less than 3 % appro- uses. priate drainage measures must have to be considered. If aesthetics are important and normal drying times ECOLOGY, HEALTH AND SAFETY are to be achieved, do not apply Sikalastic®-560 GCC top coats with consumption rates greater than 0.35 For information and advice on the safe handling, stor- kg/m2. age and disposal of chemical products, users shall refer Do not apply Sikalastic®-560 GCC directly on insulation to the most recent Safety Data Sheet (SDS) containing boards. Instead use a separation layer like Sikalastic®- physical, ecological, toxicological and other safety-re- Carrier between insulation board and Sikalastic®-560 lated data. GCC. Sikalastic® Flexitape Heavy or Sika® Reemat Premium LEGAL NOTES can be applied at areas with high movements, irregu- lar substrate or to bridge cracks, joints and seams on The information, and, in particular, the recommenda- the substrate as well as for details. tions relating to the application and end-use of Sika Sikalastic® Flexitape Heavy or Sika® Reemat Premium products, are given in good faith based on Sika's cur- can be used as total reinforcement or for partial rein- rent knowledge and experience of the products when forcements over dynamic cracks and joints. properly stored, handled and applied under normal Sikalastic®-560 GCC is not recommended for pedestri- conditions in accordance with Sika's recommenda- an traffic. In case pedestrian traffic is unavoidable, tions. In practice, the differences in materials, sub- Sikalastic®-560 GCC shall be covered with appropriate strates and actual site conditions are such that no war- paving materials. ranty in respect of merchantability or of fitness for a Do not apply cementitious products for example tile particular purpose, nor any liability arising out of any mortar directly onto Sikalastic®-560 GCC. Use an al- legal relationship whatsoever, can be inferred either kaline barrier, for example kiln dried quartz sand. from this information, or from any written recom- Sikalastic®-560 GCC is to be used mainly in exposed mendations, or from any other advice offered. The applications and is not for inverted buried systems. user of the product must test the product’s suitability Sikalastic®-560 GCC should not be subject to perman- for the intended application and purpose. Sika re- ent water immersion. serves the right to change the properties of its Whilst Sikalastic®-560 GCC is resistant to most com- products. The proprietary rights of third parties must monly encountered atmospheric pollutants, propriety be observed. All orders are accepted subject to our cleaning solutions and environmental spoilage, the current terms of sale and delivery. Users must always suitability of the product for use in applications with refer to the most recent issue of the local Product Data increased chemical resistance requirements should Sheet for the product concerned, copies of which will first be established in consultation with our Technical be supplied on request. Department. Overcoating Sikalastic®-560 GCC after 3 months expos- ure, requires adhesion tests.
SIKA NORTHERN GULF SIKA SOUTHERN GULF SIKA SAUDI ARABIA