Q vo Operator's Manual} sm
PAIS Tee a ee
Only one M code may be programmed per block. All M codes take effect or cause an action to occur at the end
of the block. However, when Parameter 278, bit ‘CNCR SPINDLE, "is set to 1, an M03 (Spindle On) will occur at
the beginning of a block.
oo
Mot
Moz
Mo3
Mo4
Mos
Mos
Mos
Mog
M10
Mt
M2
M13
M16
M17
m8
mg
M21-M28
M30
M31
M33
M34
M35
M36
M39
mat
a2
M50
M51-M58.
Msg
Mé1-Mes
Meg
M75
M76
77
78
79
go
Met
M2
M3
M84
M86
Mes
Meg
260
Stop Program
Optional Program Stop
Program End
Spindle Forward (CW)
Spindle Reverse (CCW)
Spindle Stop
Tool Change
Coolant On
Coolant Off
Engage 4th Axis Brake
Release 4th Axis Brake
Engage Sth Axis Brake
Release Sth Axis Brake
Tool Change (same as M06)
Unclamp APC Pallet And Open APC Door (used for maintenance only)
Clamp APC Pallet And Close APC Door (used for maintenance only)
Orient Spindle (P and R values optional)
Optional Pulsed User M Function with Fin
Prog End and Rewind
Chip Conveyor Forward
Chip Conveyor Stop
Coolant Spigot Position Down, Increment
Coolant Spigot Position Up, Decrement
Pallet Part Ready
Rotate Too! Turret
Low Gear Override
High Gear Override
Execute Pallet Change
Set Optional User M Code
Set Output Relay
Clear Optional User M Code
Clear Output Relay
Set G35 or G136 Reference Point
Control Display Inactive
Control Display Active
Alarm If Skip Signal Found
Alarm If Skip Signal Not Found
‘Auto Door Open
‘Auto Door Close
Tool Unclamp
Auto Air Gun On
Auto Air Gun Off
Tool Clamp
Through-the-Spindle Coolant ON
Through-the-Spindle Coolant OFF
AWS 96-8000 revG