Professional Documents
Culture Documents
Hap HLC Cide 1220
Hap HLC Cide 1220
Hap HLC Cide 1220
3. Hazard Identifications
Hazards Designations :
C Corrosive
N Dangerous for environment
Page 1 of 4
SAFETY DATA SHEET
HLC – CIDE 1220
Eye contact Rinse immediately with plenty of water for at least 15 minutes. In case of
eye irritation, seek medical attention.
Ingestion Rinse out mouth and drink plenty of water. Administer activated
charcoal. Do not induce vomiting and call for medical help
Inhalation Move to fresh air. Clear any blocked airways. If person is not breathing,
begin artificial respiration. If affected person feels unwell, seek medical
advice.
Clean-up procedures Soak up with inert absorbent material ( e.g. sand silica gel, acid
binder, sawdust ), Sweep up and shovel into suitable cantainers
for disposal.
Handling requirements Do not eat, drink or smoke during use. Remove contaminated
clothing immediately and launder before re-use. Wash hands
before breaks and immediately after handling the product. Avoid
formation of sprays or mist.
Page 2 of 4
SAFETY DATA SHEET
HLC – CIDE 1220
State Liquid
Colour Colourless to slightly yellowish
Odour Faint
Flash Point > 35 °C
Ignition temperature 425 °C
pH Value at 25 °C 5,0 – 8,0
Specific Gravity at 25 °C 0,95 – 0,97 kg/L
Acute Oral Toxicity not toxic, LD50 oral (rats) > 1000 - 10000 mg / kg
By anology to similar product
Primary irritant effect: · on the skin: Caustic effect on skin and mucous membranes.
· on the eye: Strong caustic effect.
· Sensitization: No sensitizing effect known.
· Subacute to chronic toxicity: non mutagenic (OECD 471/EPA
84-4)
Aquatic toxicity :
Page 3 of 4
SAFETY DATA SHEET
HLC – CIDE 1220
Hazard symbols
C Corrosive
N Dangerous for environment
Risk phrases R20/21/22 Harmful by inhalation, in contact with skin and if swallowed.
R34 Causes burns.
R50 Very toxic to aquatic organisms.
R68/20/21/22 Harmful: poss'ible risk of irreversible effects through
inhalation, in contact with skin and
if swallowed.
Safety phrases S26 : In case of contact with eyes, rinse immediately with plenty of water
and seek medical advice.
S36/37/39 : Wear suitable protective clothing, gloves and eye/face
protection.
S45 : In case of accident or if you feel unwell, seek medical advice
immediately (show the label where possible).
S57 : Use appropriate container to avoid environmental contamination.
S61 : Avoid release to the environment. Refer to special
instructions/safety data sheets.
Note The regulatory information given above only indicates the principal
regulations specifically applicable to the product described in the safety
data sheet. The user's attention is drawn to the possible existence of
additional provisions which complete these regulations. Refer to all
applicable national, international and local regulations or provisions.
17. Disclaimer
The information of this sheet corresponds to the actual level of our knowledge. It is not
representative for the product specifications and cannot be a base for a contractual use. The user
of the product is responsible for the observation of existing laws and directives.
Page 4 of 4