Professional Documents
Culture Documents
Loctite 518 Tech Info Sheet EN
Loctite 518 Tech Info Sheet EN
Loctite 518 Tech Info Sheet EN
LOCTITE® 518™
November-2013
include sealing close fitting joints between rigid metal faces Steel
and flanges. Provides resistance to low pressures immediately 75
after assembly of flanges. Typically used as a form-in-place
gasket on rigid flanged connections, e.g. gearbox and engine
casings, etc. The thixotropic nature of LOCTITE® 518™ 50
Aluminum
reduces the migration of liquid product after application to the
substrate. 25
NSF International 0
Registered to NSF Category P1 for use as a sealant where 1min 5min 10min 30min 1h 3h 6h 24h 72h
there is no possibilty of food contact in and around food Cure Time
processing areas. Note: This is a regional approval. Please
contact your local Technical Service Center for more Cure Speed vs. Bond Gap
information and clarification. The rate of cure will depend on the bondline gap. The following
graph shows shear strength developed with time on grit blasted
steel lap shears at different controlled gaps and tested
NSF International
according to ISO 4587.
Certified to ANSI/NSF Standard 61 for use in commercial and
residential potable water systems not exceeding 82° C. Note: 100
% of Full Strength on Steel
(psi) (1,100)
°C
°C
(psi) (1,200)
5
40
°C
50
22
25
Sealing Capability
An annular shaped gasket with an inner diameter of 50 mm
0 and an external diameter of 70 mm was tested up to 1.3 MPa
1min 5min 10min 30min 1h 3h 6h 24h 72h for leakage (immersion in water for 1 minute).
Cure Time
25 Activator 7649™ 75
No Activator
0 50
1min 5min 10min 30min 1h 3h 6h 24h 72h
Cure Time
25
TYPICAL PROPERTIES OF CURED MATERIAL
Physical Properties:
Specific Heat, kJ/(kg·K) 0.3 0
Coefficient of Thermal Expansion, 80×10-6 0 50 100 150
ISO 11359-2, K-1 Temperature, °C
Coefficient of Thermal Conductivity, ISO 8302, 0.1
W/(m·K) Heat Aging
Aged at temperature indicated and tested @ 22 °C
TYPICAL PERFORMANCE OF CURED MATERIAL 250
% of Full Strength on Steel
100 °C
Adhesive Properties
200 120 °C
Cured for 1 hour @ 22 °C
Compressive Shear Strength, ISO 10123:
150
Steel pins and collars N/mm² ≥5.0LMS
(psi) (≥725)
100
150 °C
50
0
0 250 500 750 1000
Exposure Time, hours