Professional Documents
Culture Documents
SB - 13 50 - New Vibrating Tool For ProSpinST V2 and PLF - Ed3 - en
SB - 13 50 - New Vibrating Tool For ProSpinST V2 and PLF - Ed3 - en
ProspinST/ST V2/PLF
SB 13-50 ed3
Application: Level 2
Type:
ACTION
INFORMATION
SECURITY
Please contact the International Call Center if you have any questions about this document:
E-mail: callcenter.europe@lectra.com
Phone number: +00 800 00 532872 or + 33 (0)557 978 100
1. GENERAL INFORMATION
Vibrating tool 129179 has been replaced by a new model. The new article codes for ordering spare
parts are now 705188 for ProSpin and 705457 for a PLF.
Internal 1/7
SB 13-50 ed3
2.1 ProSpinST
2.2 PLF
Internal 2/7
SB 13-50 ed3
3. INSTALLATION ADVICE
3.1 ProSpin
To install the new tool, the head anti-rotation axis should be moved as follows:
Warning: On the ProSpinST and ST V2, prior to 11L0621, there is no threaded hole for the new fixing. It should be
created using the following plan.
Before:
Anti-rotation axis
After:
Anti-rotation axis
Internal 3/7
SB 13-50 ed3
Warning: The new position of the anti-rotation axis prevents the use of the current zero blade setting device. The new part
to order is 139632.
Internal 4/7
SB 13-50 ed3
3.2 PLF
To install the new tool, the head anti-rotation axis should be moved as follows:
Before:
Anti-rotation axis
After:
Anti-rotation axis
Internal 5/7
SB 13-50 ed3
You may need to drill a threaded hole if it does not already exist. Use a 2.5 mm drill to
make an M3 threaded hole at least 8 mm useful depth as shown on the following plan .
Here there is no need to replace the current zero blade setting device.
When moving from V2 to V3, order the 410488A screw (HC cup point screw M 3-10 45H NF E 27-183).
Internal 6/7
SB 13-50 ed3
4. TOOL IMPROVEMENTS
The new tool is easier to maintain as it is removable. The following elements can be replaced:
Washers 128437
5. LOGISTICS
Internal 7/7