Professional Documents
Culture Documents
BEAM Motorized
BEAM Motorized
BEAM Motorized
Intelligent
Auto-Aligning Beam Detector
Technical data
All data is supplied subject to change without notice. Specifications
are typical at 24V, 25°C and 50% RH unless otherwise stated.
The Intelligent Auto-Aligning Beam Detector combines a Standards & approvals EN 54-12, EN 54-17, CPR, LPCB and
transmitter/receiver in the same detector head with an automatic VdS
alignment motor. This combination with integrated addressability Dimensions:
allows for quick and simple installation. Controller with base 230mm height x 202mm width x
87mm depth
The Intelligent Auto-Aligning Beam Detector automatically
Detector with base 131mm height x 134mm width x
compensates for environmental effects on the beam signal, 134mm depth
keeping the unit in the best possible working order. This is achieved
Universal bracket 135mm height x 135mm width x
through the combination of software (automatic gain control) and 71mm depth
motorised realignment of the beam.
Reflector 100mm height x 100mm width x
IMPORTANT: A second detector head uses the controller address 10mm depth
plus 1. Weight:
• Loop Powered and compatible with XP95, Discovery and Controller with base 1000g
CoreProtocol* Detector with base 537g
• Incorporates a bi directional short-circuit isolator Universal bracket 200g
• Automatic drift compensation Reflector 100g
36 Brookside Road, Havant Tel: +44 (0)23 9249 2412 Email: sales@apollo-fire.com
Hampshire, PO9 1JR, UK. Fax: +44 (0)23 9249 2754 Web: www.apollo-fire.co.uk
MANAGEMENT
SYSTEMS
MANAGEMENT
SYSTEMS
PRODUCT
CERTIFICATION © Apollo Fire Detectors Limited 2018
Assessed to ISO 9001:2008 Assessed to ISO 14001:2004 Cert/LPCB ref. 010
Cert/LPCB ref. 010 Cert/LPCB ref. 010 EMS
PP2510/2018/Issue 3
Intelligent Auto-Aligning Beam Detector Page 2 of 4
A fault is indicated by the amber LED flashing every 10 seconds. System controller is powering
16 Controller powering up up but has yet to establish
If the drift compensation function has reached its limit the communication with detectors
amber LED flashes once every 10 seconds an error code is
displayed on the ground level controller and an analogue value 25 Normal condition
of 6 is transmitted. The detector will continue to function but
maintenance procedures should be carried out at the earliest 48 Pre-Alarm Pre-alarm threshold reached
opportunity.
Alarm threshold reached.
64 Alarm Note: Beam detector heads
are non-latching
PP2510/2018/Issue 3
Intelligent Auto-Aligning Beam Detector Page 3 of 4