Professional Documents
Culture Documents
DIR-825 I1 Mesh Setup - EN
DIR-825 I1 Mesh Setup - EN
DIR-825 I1 Mesh Setup - EN
To configure a mesh network, you will need two or more D-Link routers with support of the
EasyMesh function. One of the routers connects to the Internet and serves as the controller, other
devices connect to the controller via Wi-Fi or with an Ethernet cable to serve as agents and
extend the network.
Controller: Ensures the centralized configuration of agent devices, controls the roaming of
clients and determines the best data flow routes between agents.
Agents: Serve as Wi-Fi access points for client devices, gather data on their connection quality,
and execute commands from the controller.
Connect an agent device to a LAN port of the controller with an Ethernet cable. Wait 2-4
minutes for the agent to receive all mesh network settings from the controller, including SSID
and password.
Make sure the connection is successful. To do this, in the web-based interface of the controller,
on the EasyMesh page, check the information on connected agents.
Method 2. Connection with the hardware WPS button
Press the WPS button on the controller and an agent (or an agent and an additional agent).
Important! Do not press the WPS button on more than two devices simultaneously.
Wait 2-4 minutes and make sure the connection is successful. To do this, in the web-based
interface of the controller, on the EasyMesh page, check the information on connected agents.
Method 3. Connection with the ESTABLISH CONNECTION button in the web-based interface
Press the ESTABLISH CONNECTION button in the web-based interface of both devices.
Important! Do not press the ESTABLISH CONNECTION button on more than two devices
simultaneously.
Wait 2-4 minutes and make sure the connection is successful. To do this, in the web-based
interface of the controller, on the EasyMesh page, check the information on connected agents.
Your mesh network is configured. Repeat steps 2 and 3 to connect additional agents.