Professional Documents
Culture Documents
Ee 11
Ee 11
• iir•c-%. to'''.
7-;/'
II
TESTYOURSEL,E:
6. Three 1100/110-V transformers connected delta-delta is
supplying a lighting load of 100 kW. Find the current in each transformer secondary winding.
A. 909 A C. 525 A
A. 303 A D. 255 A
which of the
7. Three 10:1 single-phase, step-down transformers are connected
r-delta In wye-delta. For a primary line to line voltage of 3980 V, find the corresponding line voltage on the secondary side.
A. 398 V C. 230 V
B. 22,978 V D. 132 V
8. A 2-MW, 2400-V, 0.75 pf load is to be supplied from a 34,500 V, 3-phase line through three single-phase transformers connected
wye-wye. Find the voltage rating of each transformer.
or parallel
A. 20000/1386-V C. 18000/1300-V
gements is
B. 18500/1350-V D. 19000/1350-V
TESTYOURSELF: V)'32
1. Which of the following transformer banks will give the least N 1
2-5V Y
secondary line voltage? 4 0.4, So
A. Star-star C. Delta-delta
VI. •- V ^.59V-1./
B. Delta-star D. Star-delta
\ _
-
Vp NI
%.21
I<; V
Ve4 ti ro Aof r„,„, = 5(*Ip‘-;
10. Three single-phase transformers rated 40 MVA, 13.2 kV/80 kV
are connected in delta/wye on a 13.2 kV transmission line. Find
the secondary line voltage.
A. 80 kV C. 23 kV 7. Two transformers in a open-delta bank are serving a 3-
B. 146 kV D. 138 kV phase balanced load of 43.3 kVA. If a third transformer of the
same rating is added for closed-delta operation, find the new
I Orel, Dc)- 7)
" T36,■•1 rated capacity of the bank.
(KVA- r.-+;.
2
A, 7
e, _______________
115.3-4-; it
YOURziFC'IS)
6. A 3-phase load is rated 85 kVA, 3-phase. If the
bank serving the load is open-delta, find the minimum 11. A 3-phase balanced load rated 100 fCVil, 0.8 pf Is to be served by
rating on each transformer. two transformers connected open-delta. Find the minimum
(1.< VA- • rrt.,) rating of each transformer.
A. 83.3 kVA C. 623 kVA
13_ ye, a-- ,•1!) B. 72.1 kVA D. 57.7 kVA
THE BOARD EXAM IS A COMPETITION! <Page 1/13> IT WILL BE YOU AGAINST ALL OTHERS!
CamScanner
S(v-v)
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
2nd Floor, Yap Building, 35 M. Velez St , Barangay Guadalupe, Cebu City
- - - - - - - - - - - - - - - - - - - - - - - - - - - -
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
12. If one of the transformers In A-A is disabled the system can still 11. The voltage applied to the field of a rotating cylindrical rotor
continue to operate at a reduced capacity of . type alternators Is
A. 73.6% C. 66.7% A. high dc voltage C.
high ac voltage
B. 57.7% D. 50% B.' low dc voltage D. low
ac voltage
Delta-delta tste,vti
B. Star-star D. Scott :,-,-,-)•-,! i
I ly,f. P'..0-4b/ re „-1 ,) i
-
- 7 - (eld
kr‘,,,cityf -e.,.
il.,. 10. A turbo-alternator uses_______pole-field structure.
A, salient C. either A or B
,!vnon-salient D. neither A nor B
25. High voltage alternators are usually of the rotating field type. 27. With reduction of load on alternator the frequency
This means the generated voltage is connected______. A. decreases C. increases
A. through slip rings to the load D. B. oscillates D.
directly to rotor remains the same
B. through slip rings of the rotating field C.
directly to load 28. A hydraulic turbine having a rated speed of 250 rpm is
connected to an alternator. Find the number of poles required
13. Alternators are usually designed to generate definite in the alternator in order to produce power at 50 Hz.
A. currents _p frequency A. 6 C. 16
B. power factor D. all of B. 12 D. 24
these
29. An alternator is capable of delivering power at a particular
frequency. The frequency can be increased by •
A. increasing armature speed
B. reversing the armature rotation
C. increasing the current supplied to the field
electromagnets
TEST YOURSELF: D. reversing the field polarity
26. Find the speed of a 3-phase, 4-pole, 60 Hz synchronous
30. An 8-pole ac generator is running at 900 rpm. Find the
generator.
frequency of the generated voltage.
A. 1800 rpm C. 2400 rpm
A. 50 Hz C. 75 Hz
B. 3000 rpm D. 3600 rpm B. 60 Hz D. 48 Hz
THE BOARD EXAM IS A COMPETITION! <Page 2/13> IT WILL BE YOU AGAINST ALL OTHERS!
130 CamScanner
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
2"d Floor, Yap Building, 35 M. Velez St , Barangay Guadalupe, Cebu City
of waveform
B. flux per pole D. all of these
'
15. A 3-phase star-connected, 50 Hz alternator has 96 17. A 318.75 kVA, 2300-V 3-phase Y-connected alternator has an
conductors per phase and a flux per pole of 0.1 Wb. Find armature Impedance of (0.35 + j1.2) f) per phase. Find
the induced emf per phase. Assume distribution factor the line to line generated voltage at full load and 0.8 pf
equal to 0.96. lagging
e,
-" ,
7 yoti ;,
“r I
7) _ . i.e/T.Ltzi •
( (r. - 77 ( . " • 1 ' ? .1 ) '±rp ;,-, Lt.
.;
a .01,‘.;) 4(.50( . .
u
TEST YOURSELF:
16. A 3-phase, 2-pole, 50-Hz,llitar-connect alternator has 37. A 3-phase, 500-kVA, 1100 V, wye-connected alternator
9 slots per pole and 6 conductors per slot. Find the flux has a stator impedance of (0.1 + 11.5) c2 per phase. The
per pole if the line to line voltage on open circuit is 1100 alternator is supplying full load at unity pf. Find the
V. Induced emf per phase.
A. 769 V C. 692 V
B. 832 V D. 935 V
y _2 qY
ig= Pa()
A. 0.067 0 C. 0.044 LI
B. 0.1 0 D. 0.15 (2.
V 6 I 1 (0 , 1 - I X- T3
(..vCi• I
().9111,1. <• `) 1401 f• 11,1i 1- V
V1 =
\ J r r
vp '2 • 3
%I',
'J./A
' •14. to •)1'1'it,
t
-.... • ''1
e' r**1 1)7C
C i)4. (1)1;141) (ti.Y; N
TEST YOUKLLEi
19. A 3-phase alternator gives a short circuit current of 600 A 13.22.24% . D. 24.42%
for a given field excitation. With the same excitation, the
open circuit voltage was 900 V. Find the synchronous 50. In an alternator terminal voltage rise will bemore ,
reactance per phase if the effective resistance between a A. when leading load Is thrown off
pair of terminals Is 0.18 0. B. when lagging load is thrown off
l''•..t.rvie fdli'KVi.)., C. when unity power factor load Is thrown off
D. none of these
?I) 0•12.A
('"fer- 4-49P. r-40011-5
F. 51. A 25 kVA, 3-phase, wye-connected, 400-V synchronous
't--
'1(014,) 'AG &u) generator has an impedance of (0.5 -r- J1.6) 0 per
phase. Find the full load voltage regulation at unity pf.
o.-012 A. 1122% C. 13.56%
B. 12.57% D. 10.64%
TEST YOURSELF;
52. Voltage regulation of an alternator Is usually that of a
45. The ac resistance of a star-connected alternator Is 0.5 0 power transformer.
per phase. At a certain field current, It produces an A. equal to C. much lower than
armature current of 200 A on short circuit and an open 8, much higher than D. none ofthese
circuit terminal voltage of 1040 V. Find the synchronous
reactance per phase. 53. A 3-phase, 318.75 kVA, 2300 V, Y-connected alternator has a
A.2.96 0 C. 2.69 0 synchronous Impedance of (0.35 + j1,2) Q per phase. Find
B.2.87 Cl D. 2.78 the voltage regulation at full load, 0.6 pf leading and
rated voltage.
46. Synchronous Impedance of an alternator Is defined as the
A. -3.71% C. -4.11%
ratio 13. -4.33% D. -5.17%
of
A.short circuit voltage to short drcult current V P"#4`1" e (./ .1.4
B.open circuit vottage to open circuit current
C.short circuit current to no load current 1.7,1•:..,(<
D.open circuit voltage to short circuit current p Pay' ProiCr (..A,e{t}i0 ► 1:.
47. A single-phase alternator has an effective armature CY I Ou
resistance of 0.5 0. At a given exdtation, the short circuit •
current Is 200 A with a corresponding open circuit emf of
1160 V. Find the synchronous reactance.
A. 5,778 Cl C. 5.556 Cl
p\J
8. 5.633 D D. 5.482 Cl
k i• L.77\71,Z0 (Jr i! &)(1)(p
48. A 3-phase star -connected alternator has an armature
resistance of 0.9 0/phase. A field current of 5 A was
necessary to produce a short circuit current of 100 A.
The open clrcult ernf for the same excitation was 900 V. c ( Pit/$.9
find the reactance per phase. f.0),) Pity Ph;•ke
C Yy) tr 1.)*
A. 5.196 0 C. 5.1170 pos eJ e.
U. D. 5.216 1/
5 , 2 0 2 0
19. A 3•phase, 10 kVA, 230 V, wyc connected alternator has a
synchronous Impedance of (0.5 + J1.2) f2 per phase.
Find the voltage regulation at full load with 0.85 pf
lagging.
A. 18.68% C. 20.83%
6••••,--) '1,(V Alt)
THE BOARD EXAM Is A COMPETITION! <Page 4/13> IT WILL LIE YOU AGAINST ALL OTHERSI
- masseav sawmi si dn it •IF i t# V111.11iiiiii11111111•ft
X ri
CamScanner
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
Pi I lour, Yap lidding, 35 M. Velez , Barangay Guadalupe, Cebu City
er
it A 3 phase, II kV, wye t thine( gene►atot ha,. a synclitoneun
rvaclance of 6 t) per phase and negligible lesIstance. For a
given held (intent, the open tilt' tilt voltage is 12 kV, rum the
annature intent fur maximum power wh►lition,
TESLYOURS[lf laTIQIIRSELF:
51. A 2,1 MVA, 1/.32 kV, 3-phase, 60 lir alternator has 59. A 3-phase, 2.5 MVA, 6.6 kV, 60 Hz, star-connected alternator has
reactance of 5 0/phase and negligible armature armature resistance of 0.05 c1/phase. The field loss is 3.75 kW. The
resistance, The excitation voltage is maintained at 13.4 kV/phase stray power losses are 82 kW. Find the efficiency at full load, 0.85 pf
and the terminal voltage at 10 kV/phase. Find the maximum lagging.
3•phase real power that the generator can develop. A, 95.81% C. 94,23%
A. 80 MW C. 88 MW 0, 96.24% D. 97.52%
B. 92 MW D. 96 MW
60, A 500-kVA alternator operates at full load kVA output at an
55. A 3-phase, 11-kV wye-connected alternator has a synchronous efficiency of 93.5%. If the load power factor is 0.83. Find the
reactance of 8 0/phase and a negligible resistance. If the excitation total loss.
is such that the open circuit voltage is 14 kV, find the armature A. 28.85 kW C. 25.18 kW
current at maximum output condition. B. 22.48 kW D. 20.41 kW
A. 2225 A C. 2295 A
13. 2.245A D. 2265 A 61. A 3-phase, 2 MVA, 2.3-kV, Y-connected alternator operates at
rated load, 0.85 pf lagging. The ac armature resistance per phase
56. A 3-phase, 11-kV, 5 MVA alternator has a synchronous reactance is 0.052 L2. The field takes 72 A at 125 V, Stary power losses are
of 10 Q per phase. its excitation Is such that the generated emf 58.6 kW. Find the efficiency of the alternator.
is 14 kV. Find the maximum power output at the given excitation. A. 92.85% C. 94.08%
A. 16.2 MW C. 15.4 MW B. 95.14% D. 93.37%
13. 14,3 MW D. 17.1 MW
62. A 25-kVA alternator has a total loss of 2000 watts when it delivers
57. A 24 MVA, 17.32 kV, 3-phase, 60 Hz alternator has reactance of rated kVA to a load at a power factor of 0.76. Find its percent
S 0/phase and negligible armature resistance. The excitation efficiency.
voltage is maintained at 13.4 kV/phase and the terminal voltage A. 92.47% C. 91.28%
at 10 kV/phase. Find the maximum armature current that the B. 93.19% D. 90.47%
generator can develop.
A.4562 A C. 3880 A 63. A 3-phase, 25-kVA, 220-V, wye-connected alternator has an ac
B.3344 A D. 4024 A armature resistance of 0.09 0/phase. Friction and windage loss
is 460 W. Core loss is 600 W. The field winding takes 9 A at 110
58. A 60 MVA, 69.3 kV, three-phase synchronous generator has a V. Find the percent efficiency at rated load, 0.8 of lagging.
synchronous reactance of 15 0 per phase and negligible A. 83.32% C. 84.27%
resistance. If the generated ernf is 36 kV per phase Find the B. 85.81% D. 86.16%
maximum 3-phase power that the generator can deliver. i • 5a• Sti
A. 250 MW C. 296 MW
B. 288 MW D. 248 MW
Lei (it 1 Ln'''• 12. 5A-t 5P),
= c,/ 5-7ls;a.
rApi r
P.C.; t (
(wyr) 23. Two alternators A and B operating in parallel supply 2500 kW to a load at
0.80 pf lagging, Alternator A delivers 1200 kW at 0.95 pf lagging. Find the
fz,-,= 1)
35.4(44), ??'051 kVA supplied by alternator B.
64. Two alternators A and B are operated in parallel, The total load
of the system is 1050 kW at 0.75 pf lagging. Alternator A carries
f MA2 kliv 1 1 r(i 06
700 kW at 0.80 pf lagging. Find the kVAR load of alternator B.
tV 1) (r4.17 A. 401 kVAR C. 419 kVAR
` „ „ 4 , i / _ ,
2 1 c u i t 0 B. 398 kVAR D. 518 kVAR
67. Two alternators A and B are connected in parallel. The total load
Is 4250 kW at 0.85 pf lagging. Alternator A delivers 2125 kW at
0.707 pf lagging. Find the kVA load of alternator B.
A. 2245 kVA C. 207B kVA
B. 2185 kVA D. 2410 kVA
• • • • • ■■■■••■■- ■-_ _
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
2"d Floor, Yap Building, 35 M. Velez St , Barangay Guadalupe, Cebu City
.)8. A lighting load of 1500 kW and a motor load of 2200 kW at a 26. The distribution of load between two alternators operating In
pf of 0.707 are supplied by two alternators running in parallel. parallel can be changed by changing .
One of the alternator supplies 2000 kW at 0.8 pf lagging. Find A. phase sequence
the kVA load of the other alternator. B. field excitation of alternators
A. 1932 kVA C. 1838 WA C. driving torques of prime movers
B. 1822 WAD. 1914 kVA D. all of these
TEST YOURSELF:
72.
In the input to the prime mover of an alternator Is kept constant
but the excitation of changed then ___ .
' )1_ A. the reactive component of the output is
changed
B. the active component of the output Is
changed
C. the pf of the load remains constant
73.
D. none of these
24. Two alternators A and B are operating in parallel. Alternator A is In order to transfer the load from one alternator to another
rated 1 MW and its frequency falls from 61 Hz at no-load to 59.6 alternator, when they are operating In parallel.
Hz at full load. Alternator B is rated 1.5 MW, its frequency falls A. field current is increased
from 61.4 Hz at no-load to 59.2 Hz at full load. Find the B. field current is decreased
operating frequency when total load Is 2 MW.
74. C. speed is decreased
D. prime mover power input is Increased
133 CamScanner
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
2"4 Floor, Yap Building, 35 M. Velez St , Barangay Guadalupe, Cebu City
EDCamScann
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
2nd Floor, Yap Building, 35 M. Velez St , Barangay Guadalupe, Cebu City
resistance is negligible, Find the percent voltage regulation on
- Frequency Relay
full-load at 0.8 pf leading.
2 - DC Reclosing Relay A. -15.7% C. -13.8%
e Automatic Selective Control or Transfer Relay
- B. -21.5% D. -18.7%
84 Operating Mechanism
-
Past_Board Question 97. A 50-hp, 440-V, 3-phase motor with an efficiency of 0.90 and a
What is the device function number of a directional power relay? pf of 0.85 on full load is supplied from a 6600/440-V, delta-star
A. 27 C. 30 connected transformer. Find the current in the low voltage
B. 32 D. 37 phases.
A. 49 A C. 55 A
Past Board Question B. 64 A D. 72 A
What is the IEEE device number for AC circuit breakers?
A. 52 C. 50 98. A 60-cycle synchronous motor is coupled to and drives a 50-
B. 55D. 51 cycle alternator. At what speed does the motor-generator
operate?
Past Board Question A. 400 rpm C. 500 rpm
Overvoltage relay device function number is . B. 300 rpm D. 600 rpm
A. 64C. 56
B. 60 D. 59 99. Which of the following connections in a three-phase transformer
is called open delta connection?
Past Board Question A. Y-Y C. 4-,1
Device number 87 Is the device function number assigned to . B. D . V - V
A. undervoltage relay C. lock out relay
B. directional relay D. 100. To monitor the voltage of a 230-kV line, PTs are to be installed.
differential relay The PTs are to be connected delta-delta. The desired secondary
voltage is 115 V, 3-phase. Find the PTs voltage ratio.
CONSTANT PRACTICE MAKES YOU PERFECT! A. 230 kV/115 V C.
132.79 kV/115 V
87, Three single-phase step-up transformers rated 132/80-kV are B. 230 kV/66,4 V D.
connected in delta-wye on 13.2 kV transmission line. Find the 132.79 kV/66.4 V
secondary line voltage,
A. 138.56 kV C. 132.28 kV 101. A 3-phase, 60-MVA, 69.3 kV, wye-connected alternator has a
B. 136.42 kV D. 134.46 kV synchronous reactance of 15 a per phase and negligible
resistance. The generator is delivering rated power at 0.80 pf
88. For the same rating, the size of low speed alternators is that lagging at rated terminal voltage. Find the power angle.
of high speed alternators. A. 6.37° C. 9.47°
A. about the same C. more than B. 7.67° D. 4.54°
B. less than D.
none of these 102. The distribution transformer is generally connected in
A. Delta-delta C. Wye-wye
89. A 500 kVA, 6-pole, 500 V, 3-phase, wye-connected synchronous B. Wye-delta D. Delta-wye
generator has a synchronous impedance of (0.1 + j1.5) c per
103. A 3-phase, 10-hp, 230-V, Y-connected synchronous motor has a
phase. If the generator is driven at 1000 rpm, Find the power
reactance of 3 Q per phase and a negligible resistance. To what
angle on full load and 0.B pf lagging.
A. 33.5° C. 39.4° voltage must the motor be excited in order to deliver full load at
B. 37.6° D. 42.2° unity power factor and 90% efficiency?
A. 252 V C. 254 V
B, 248 V D. 242 V
90. Regulation of an alternator is defined as the rise in terminal
when full load is thrown off. 104.A 3-phase power transformer rated 50 MVA, 34.5 kV/13.8 kV
A. current C. voltage is connected wye- delta, Find the full load current in each of the
B. rating D. power factor secondary winding.
A. 2092 A C. 1208 A
91. Two wye-connected identical, synchronous generators operating B. 1488 A D. 1054 A
in parallel, share equally a 1-MW load at 11 kV and 0.8 lagging
power factor. If one machines supplies 40 A at a lagging power 105. A 3-phase, Y-connected, 75 MVA, 27 kV synchronous generator
factor. Find the current of the second machine. has a synchronous reactance of 9 ohms per phase. Using rated
A. 28.7 A ' C. 26.7 A MVA and voltage as base values, determine the per unit
B. 27.8 A D. 27.6 A reactance.
C
92. An ac generator has 10 poles and running at 600 rpm. Find the A. 0.882 pu C. 0.926 pu
frequency of its generated voltage. D
B. 1.142 pu D. 2.107 pu
A. 40 Hz C. 60 Hz
B. 50 Hz D. 70 Hz 106. Which type of connection is used for both large voltage and low
voltage rating transformers?
93. Find the minimum kVA rating required on each of the two A. Delta-delta connection C.
transformers connected open delta supplying a balanced three- Delta-wye connection
phase load of 40 kVA. B. Wye-wye connection D.
A. 23 C. 20 Wye-delta connection
B. 69 D. 13
107. A 220-V, 3-phase alternator is running at 300 rpm and has 24
94. A 30 kVA, 3-phase, 230 V wye-connected synchronous generator
poles. Find the total number of conductors in the stator winding
has a synchronous reactance of 0.8 0 per phase. The armature
if the magnetic flux is 50 mWb per pole.
A. 60 C. 57
B. 66 D. 55
THE BOARD EXAM IS A COMPS_________________i I i ION! <Page 8/13> IT WILL BE YOU AGAINST ALL OTHERS!
CamScanner
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
2nd Floor, Yap Building, 35 M. Velez St , Barangay Guaddlupe, Cehu City
S.Three 1:5 transformers are connected In delta-wyi to 119.The effect of increasing the load on a synchronous
step up the voltage at the beginning of a 13.2 kV motor running with normal excitation is to _
three-phase transmission line. Find the Ilne voltage on A. decrease both armature current and
the high side of the transformers, power factor
A. 38.1 kV C. 66 B. decrease armature current but Increase
kV power factor
B. 68.6 kV D. 114 C. Increase armature current but decrease
kV power factor
D. increase both its armature current and
109. An alternator Is sometimes called a generator, power factor
A. hydraulic C. wind
turbine 120. Find the required speed of an 8-pole alternator in order that
B. synchronous D. the frequency of its generated voltage shall be 40 Hz.
direct current A. 500 rpm C. 600
rpm
110. Three identical single-phase transformers with a turns- B. 400 rpm D. 700
ratio of 1:5 are connected in delta-wye from a 400-V, 3- rpm
phase source. Find the line to line voltage on the load
side. 121. The most familiar application of zigzag transformer is
A. 2,000 V C. 80 V A. converting single-phase to two-phase
B. 138.56 V D. B. as ground reference on an ungrounded
3,464 V system
C. redudng harmonics
111. Synchronization of alternators means D. all of these
A. connecting alternators in series
122. A 3-phase Y-connected alternator delivers a unity pf load at
B. transferring load from one alternator to
another 230
C. connecting alternators in parallel V. If the synchronous reactance voltage drop Is 60 V/phase and
D. adjusting the excitation of the
alternators
THE BOARD EXAM IS A COMPETITION! <Page 9/13> IT WILL BE YOU AGAINST ALL OTHERS!
CamScann
ROJAS ELECTRICAL ENGINEERING REVIEW CENTER
rd Floor, Yap Building, 35 M. Velez St , Barangay Guadalupe, Cebu City
6. A 3-phase )1-connected, 75 MVA, 27 kV synchronous generator rated load at 0.8 pf lagging. If the synchronous impedance is
has a synchronous reactance of 0.926 pu based on rated MVA (0.5 + j10) 0 per phase, find the power angle.
and voltage. Determine the new per unit value referred to a 100- A. 12.45° C. 18.97°
MVA, 30-kV base. B. 16.73" D. 15.26°
A. 1.4 pu C. 1.2 pu
B. 1.6 pu D. 1.0 pu 151. Majority of alternators in used today are of revolving type.
A. armature winding C. core
137. Which of the following 3-phase connections of a transformer
causes Interference to the nearby communication systems? B. stator D. field
A. Delta-delta C. Star-delta
152. Two identical transformers bank open-delta serve a balanced
B. Star-star D. Delta-star
3-phase load of 20.8 kW, 0.8 pf lagging at 240 V. Find the
138. Three 1:10 transformers are connected delta-wye for stepping minimum kVA size of each transformer to serve this load.
up the 2.3 kV three-phase source. Find the secondary line A. 15 C. 12
voltage. B. 36 D. 45
A. 13.8 kV C. 23 kV
153. An alternator has 8 poles. Find the frequency of its generated
B. 39.8 kV D. 16.4 kV
voltage if the alternator is driven at 600 rpm.
139. Which type of connection is made when two single-phase A. 40 Hz C. 60 Hz
transformers are to provide a three-phase supply? B. 30 Hz D. 50 Hz
A. Star connection C.
154. A 3-phase, 440-V, Y-connected synchronous motor draws 9 kW
Delta connection
and a lagging pf of 0.8 at rated load. The synchronous reactance
B. Open delta connection D.
per phase is 10 Q. Find the torque angle.
Any of these
A. 34.33° C. 32.51°
140. A single-phase, 2000-V alternator has armature resistance and B. 35.51° D. 33.46°
reactance of 0.8 Q and 4.94 Q respectively. Find the voltage
regulation of the alternator at 100 A load at 0.8 leading pf 155. Three to three phase transformer connection not feasible for
parallel operation is
A. -7.2% C. 14%
B. 11% D. -8.9% A. Y-Y and Y-Y C. Y-Y and A-A
B. Y-A and A-A D. Y-A and A-Y
141.The magnitude of field flux in a 3-phase synchronous motor .
156. A 3-phase alternator rated at 50 MVA, 22 kV has a synchronous
A. remains constant at all loads C. varies with
reactance per phase of 5 pu on its thermal rating. Find the pu
speed
value of this reactance on a base of 100 MVA and 220 kV.
B. varies with the load D.
varies with power factor A. 25 pu C. 1 pu
B. 12.5 pu D. 0.1 pu
142. A 2 MW, 2.4 kV, 0.75 pf load is to be supplied from 34.5 kV,
3-phase line through three single-phase transformers banked 157. Slip rings in a synchronous motor carry
wye-wye. Find the primary line current in the bank. A. direct current C.
alternating current
A. 50 A C. 60 A
B. no current D. either A or C
B. 45 A D. 48 A
158. A 2500 kVA, 6600 V synchronous alternator Is operating at full
143. The power drawn by the prime mover of an alternator under no
load and 0.8 pf lagging. This machine has a reactance per phase
load condition, goes to .
A. meet copper losses both in armature and rotor of 10.4 c and a negligible resistance. Find the percentage
windings voltage regulation?
A. 48.56% C. 42.35%
B. produce power in armature
C. meet no-load losses B. 45.84% D. 43.96%
D. produce emf in armature windings
159. Which of the following is the correct use of delta-delta
144. The armature of a 3-phase, 8-pole, 900 rpm alternator is wye- connections?
connected, and has 72 slots with 10 conductors per slot. The A. This connection is economical for HV
winding factor is 0.96. If 2400 V is measured across the line, transformers
find the flux per pole. B. Thus is used for smaller power systems
C. Thus is the best match for ultra HV
A. 45 mWb C. 30 mWb
transformers
B. 18 mWb D. 24 mWb
D. This suits large LV transformers
145. The slip ring employed in a 3-phase synchronous generator are
insulated for . 160. Two single-phase distribution transformers are banked in open-
A. output rated voltage C. low voltage delta. If each transformer is rated 37.5 kVA, find the maximum
B. very low voltage D. 3-phase kW load that the bank can carry without overloading,
considering that the load has a pf of 0.85 lagging.
very high voltage A. 65 kW C. 60 kW
B. 50 kW D. 55 kW
146.A 10 MVA, 69 kV/13.8 kV, 3-phase transformer is connected
wye-delta. Find the kV rating of the secondary lines.
161. In a three-phase transformer, the total load carried by a V-V
A. 13.8 kV C. 7.97 kV
bank Is of the capacity of a A-A bank.
B. 24 kV D. 39.8 kV A. 66.67% C. 87.77%
147. A synchronous motor will always stop when B. 33.33%D. 57.73%
A. supply voltage fluctuates
162. A 3-phase synchronous motor is running clockwise. If the
B. load in motor varies direction of its field current is reversed
C. excitation windings gets disconnected A. the motor will stop
D. supply voltage frequency changes
B. the motor continue to run in the same
direction
148. The dc armature winding resistance between terminals of a 750 C. the winding of the motor will burn
kVA, 4,400 V, 3-phase wye-connected alternator is 0.9 Q. Find D. the motor will run in the reverse direction
the copper loss in the winding at full load.
A. 12 kW C. 13 kW 163. A 1.5 MVA, 6.6 kV, 3-phase, star connected alternator has a
B. 8 kW D. 21 kW resistance of 0.5 0/phase and a synchronous reactance of 5
0/phase. Find the induced emf per phase at rated load, 0.8 pf
149. Find the speed of a 3-phase, 36-pole, 60 Hz, synchronous motor. lagging.
A. 300 rpm C. 400 rpm A. 4128 V C. 4284 V
B. 200 rpm D. 500 rpm B. 4348 V D. 4482 V
150. A 3-phase, 10 kVA, 400 V, 50 Hz Y-connected alternator supplies 164. Low speed alternators are driven by
A. steam engines C. B. steam turbines D. either A or B
hydraulic turbines
THE BOARD EXAM IS A COMPETITION! <Page 10/13> IT WILL BE YOU AGAINST ALL OTHERS!
EDCamScanner