Professional Documents
Culture Documents
Lab 7 Thevenin
Lab 7 Thevenin
- 8
3. Compare the value between three method – calculation, experiment and simulation.
- The value of simulation method for VTH is 7.706 and for RTH is 6.088, meanwhile value of
experiment method for VTH is 7.67 and for RTH is 6.58 and then, the value of calculation method
for VTH is 7.676 and for RTH is 6.71.
- For Superposition there were resistors given which were been checked and measured by
ohmmeter and recorded on the table. The error percentage was quite small the highest error
percentage was 2.05% for current using two voltage sources and lowest error percentage was
0.0% for current using the 5v voltage source. The experimental error may include the resistance
of connecting wire and clips which might have altered the actual current values; to reduce this.
- As the conclusion, the experiment were conducted and the results obtained were satisfied.
The calculations made were verifying the theorems as the experiment come up to its end that
objective was achieved and all the theorems were verified.
FACULTY OF ENGINEERING TECHNOLOGY ELECTRONIC
DEPARTMENT,
LABORATORY MODULE 7
SEM 1 2019/2020
191392029