Professional Documents
Culture Documents
GV75 Quick Start
GV75 Quick Start
Quick Start
Page 1 : Basic Operation
Check Parts List Open the case
The 12V DC power supply, USB‐232 data cable,
UART cable and extension cable are not in the
delivery list. Please contact your vendor
for it.
i n k
l l
Install a SIM Card
c
Close the case and tighten the screw
u e t i a
Q fide n
Find
C
“PL2303_Prolific_DriverInstaller_v10518.zip” cable, UART cable and 12V DC power supply.
in developer suite and install the drive for
PL2303. If you have already installed it, please
go to Step 6.
To computer
To Molex 8pin
connector
Find “Queclink GV75 Manage Tool Before using GV75 for the first time, please
Vx.xx.exe” in developer suite and run it to fully charge the battery and connect the
configure the running parameters of GV75. cables correctly.
Please refer to Page 2 for details. Colour Description
Red Power
Black Ground
Yellow Digital input
White Ignition
Green Digital output
Blue Digital output
Violet TXD
Grey RXD
Run the Manage Tool. Select correct COM port and If you want to test GV75 by SMS, then
input default password “gv75”. Then press “OK.” set “Report Mode” to “SMS” and input
the phone number intended to receive
SMS from GV75. After that, you can go
to Step 6.
k
Set “Report Mode” to “TCP Short Connec‐ Please contact your SIM card provider and
tion”. Input the IP address and port number get the APN information for GPRS. Input it
n
of the backend server. Please make sure the IP in GTBSI setting.
l i
address can be accessed over the internet and
l
the data sent to this address can be received.
e c t i a
u
Q fide n
Press the “Send” button and update the
parameters of GV75. Then GV75 can re‐
port information to your backend server
Set the parameters of fixed time report so
that GV75 will report its position to the
n
backend server periodically. Press “Send” but‐
or SMS receiver.
ton to update the parameters.
o
The following screenshot shows how to con‐
figure GV75 to report its position every 3 min‐
C
Command has been accepted when utes.
the window below appears.
After these steps, GV75 will have
some basic tracking functions like
The following screenshot shows how to
fixed time report and Geo‐Fence. For
create a Geo‐Fence rule. Press “Send”
button to update the parameters. other advanced functions of GV75,
please refer to “GV75 @Track Air In‐
terface Protocol” or visit our website.
http://www.queclink.com
sales@queclink.com Queclink
Grace Wang Checked
2017.12.28