Professional Documents
Culture Documents
J02622PH - Balayan Sports Complex - CO 02 - 01.10.2022
J02622PH - Balayan Sports Complex - CO 02 - 01.10.2022
E
Quote No : PH-Q076-22 Rev No: 02 Date: 8-Jun-22 For order entry ✘ For Quotation V
Name : Email:
Phone: Fax:
BUYER
7
(Invoice To) Address:
CONSIGNEE Contact Person: Position:
Name : same as buyer Mobile:
8 Phone: Fax:
SHIPMENT
Address: Email:
14
PRIMARY Surface Preparation : Power clean ST3 ✘ Shot-Blasting SA 2.0 Shot-Blasting SA 2.5 Hot-Dipped Galvanized
MEMBERS
Purlin Clip to Column / Rafter: Yes ✘ No
PRIMARY
15 MEMBERS
PAINT SYSTEM
Purlin Z275, G450, Please design the most economical purlin, girt spacing:
type Lapping VIS Standard Note:
45.0kN/cm2 Z- Purlin Depth can be: Z150, Z200, Z250, Z300
Surface Preparation: Wash Primer Treatment over Galvanized
✘ Pre-Galvanized Special Paint Over Galvanized
Paint System: Special Paint (see below)
Coat No. DFT (microns) Paint Type Manufacturer Color
SECONDARY
MEMBERS
(Purlins, girts, eave
16 strut, flange brace,
sag arrestor)
Standard is Pre-
Galvanized
17 ATTACHED ✘ GDS ✘ BDS1 ✘ BDS2 BDS3 Rev./C.O ✘ Customer Drawings Sketch Drawing
18 CHECKING Filled by: INO RODRIGUEZ Checked by: Date: 8-Jun-22
Primary member : ASTM A572 Gr.50 or equivalent having Min. yield stress 345N/mm2
3 STEEL GRADE Secondary member : ASTM A653 SS Gr.65 or equivalent having Min. yield stress 450N/mm2
Frame Type : Clear Span (CS) Slope : 3/31.450 Height (m) : 7.70 Clear H
Bldg. Width (m): 54.50m int to int of steel column Width modules: See below
Length (m): 55.82m center to center of steel column Ridge Condition: Symmetrical
Bay Spacing (m): Use the most economical bay distance (BY VIS) Columns support: Designed by Engg.
1. FFL is at Elev. +0.00m
4
BUILDING 2. Finished Grade Line is at Elev. +/-0.00m
PARAMETERS 3. Top of Pedestal is at 1.50m and measured from FFL +0.00m
Left End Wall Frame: See DWG Wind Col. Spacing (m):
Right End Wall Frame: See DWG Wind Col. Spacing (m):
ENDWALL Left End Girt type: No girt Right End Girt type: No girt
5
CONDITION Near Side Girt type No girt Far Side Girt type By-Pass
By Others Color:
7 ROOF Insulation by By VIS Steel By Others
Thickness: WMSK Density:
WALL TRIM
10
COLORS Color of other flashing, trim :
N
Bldg No: 1 Area No: 1 o
Job No : J02622PH CO No: 0 Date: 30-Dec-99
This area only: Page 2 of 2
Wall Location Soffit Panel Insulation ###
ROOF Quantity Width (M) Length (M)
Location Grid Lines By Description Yes/No By Description
EXTENSION
(Roof Panel is NSW 2 58.5
same as main
roof panel) FSW 2 58.5
LEW 2 59.82
11
REW 2 59.82
12 CANOPY
Wall Length Proj. Location Fascia panel Soffit panel Backup panel
Qty Type Height (M)
Location (M) (M) Grid Lines By Description By Description By Description
13 FASCIA
FRAMED
14
OPENING
15 MEZZANINE
MONITOR VIS Steel Scope: Only Apply Loads Design and SupplyScope of Supply: None
Columns+ Beams+Joists+Decking ###
Design Loads KN/m2 Width Length Clear Ht. Floor Handrail Location
No.
Dead Load Live Load Other Load (M) (M) (M) Type T (mm) By Type Length (M) Grid Lines
ROOF
18 PLATFORM /
WALKWAYS
Min. Hook
Scope of Supply: Only Apply Loads Crane Beams & Brackets✘ Rails
Wheel
✘ Crane system ✘ Bracket only
Power Supply. Volts: Hz: Phases: Bumper
Manufacturer:
Crane Span Runway Length Capacity Wheel Base Top of Crane Bridge Trolley Operation
No.
Type From To From To (M.T.) (mm) beam (mm) Weight (kg) Weight (kg)
Width (m)
GL GL
L (m)
GL GL Height Type
(mm)
Load (mm)
(kN)
CRANE
20
INFORMATION
21 ATTACHED ✘ For This Building/ Area Only ✘ BLDG.Data Sheet 2 ✘ BLDG.Data Sheet 3 ✘ Rev./C.O.