Professional Documents
Culture Documents
M - Exercise No. 2c
M - Exercise No. 2c
M - Exercise No. 2c
EXERCISE No. 2
FLOOR PLANS
Directions: Using the same operation below. Draw the floor plan area.
Use mm in dimensioning
Performance Assessment:
• Accuracy
50 pts – the output is accurately done.
45 pts – two to five errors re observed on the output.
40 pts – six to ten errors are observed on the output
• Speed
10 pts – the output submitted on time
5 pts – the output is submitted after the deadline
• Lettering/Labeling
15 pts - all pieces of information are completely indicated and legibly printed in gothic letters or
mechanical lettering.
12 pts. - all pieces of information are legibly printed but some are missing.
10 pts. - all pieces of information are legibly printed but some are missing and misspelled.
8 pts. - pieces of information are not legibly printed and words are misspelled.
STEPS IN DRAWING A FLOOR PLAN
5. Lay out the position of doors and windows by center line and by their widths with a 4H pencil. The
standard width of doors is 90-95 centimeters like the main entrance door. While 80 centimeters
for 85 bedrooms and service doors and 75 centimeters for toilet and bath doors.
6. Label each part of the floor plan. Draw the kitchen and apply the work triangle principle in
designing the kitchen. Draft the toilet and bath draw the fixtures properly.
7. Lay-out extension lines. Use any dimension limits and lay out dimensions legibly and never repeat
dimensions.
8. Draw the schedule of doors and windows. Name doors and windows by sizes. Finally, draw the
roof line of the floor plan.