Professional Documents
Culture Documents
Elmeasure Accl Accl300 Programming Guide
Elmeasure Accl Accl300 Programming Guide
com
Ph: +91 80 32904489
PROGRAMMING
MANUAL
3.3 Display
2. KEY & LED INDICATION Programming Default Option/Range
Parameter
VA selection (UA) Vector Harmonic / Vector/
1 Value Indication (vector harmonics) Arithmatic
2 EB - Power Baud rate (bA) 2400 to 19.2k
3 Trip
4 OLD Parity (Pr) Even/ Odd/ no
5 DG - Generator
Device Id (dU.) 1.000 to 247.0
6 Communication
Password (PW) 1000 to 9999
7 To view the Energy (EN) (rESL / COUN)
parameters
Upwards. Energy Selection(ES) Wh/VAh
8 To view the DG Under voltage(VL) 180V to 210V
parameters
Downwards and DG Over voltage(VH) 240V to 270V
Reset during trip
DG max current limit(dA) 0 to 40A/63A/80A/100A/125A
L
O 144 mm
A
D
7.5 mm
RS 485
15 mm
144 mm
127 mm
105 mm
EB
iACCL DG
15 mm
1 mm
124 mm
183. mm
186. mm
iACCL M 300
163mm
FP SP
MCB MCB
Fuse
3o K.W.H Meter
5 mm
EB BUS BAR 10 mm
Incoming DG BUS BAR
Manual COS
supply b) iACCL M 300 ( 3 phase, 63A & 80A Rating ): Surface Mount
SP - Single Pole
EB DG
FP - Four Pole
218mm
EB 3 Phase & DG 3 Phase
195mm
iACCL M 300
305. mm
310. mm
285mm
310mm
265mm
FP FP
MCB MCB
Fuse
3oK.W.H Meter
10mm
EB BUS BAR
Incoming DG BUS BAR 238mm
supply
EB DG 5mm
INFORMATION CAUTION
Manufacturer assumes no responsibility for a hazard or damage caused by incorrect During normal operation of this instrument, hazardous voltages are present at the
or non-application of any of the instructions mentioned herein. ELMEASURE shall rear terminals, which may cause injury or death. Installation, disconnection or
not be liable for any consequential or resulting injury or for loss, damage or expense removal of the meter should be carried out only by qualified, trained personnel,
directly or indirectly from the use of this product under any circumstances. after de-energizing connected circuit. The warranty will become void incase the seal
ELMEASURE does not claim any responsibility for the damage caused by using the is broken, improper installation as well as improper grounding.
product directly or indirectly as sufficient care has been taken to provide all
information regarding the product. The user is advised to use according to the
operating instructions, professional practices, wiring rules, codes, safety regulations
applicable to the given installation.