Professional Documents
Culture Documents
Installation Manual: I. Accessory Parts
Installation Manual: I. Accessory Parts
INSTALLATION MANUAL
Applied Machines: 362/282/222/350/250/200
MFP: 36 ppm/28 ppm/22 ppm/35 ppm/25 ppm/20 ppm
Product Code: A11U/A11V/A11W/4040/4041/4042
12. Label B
1
(Super G3
label) 1
4551IXC002DA
1 13. CD-ROM
4551IXC003DA
1
4. Screw
3 4040IXC111DA
14. Software
4551IXC004DA
License 1
5. Cable Agreement
1 15. Installation
Manual
4551IXC005DA 1 set
6. Battery
4980IXC019DA
7. Tie Band
4980U018AA
4551IXC008DA
After unpacking, be sure to get rid of the
9. Wiring Saddle packaging materials and keep them out of
the reach of children.
4
Putting your head in the wrapper involves
4551IXC009DA danger of suffocation.
AM1-000202-005 4040-7181-05
E-1
II. Installation procedures 5. Remove the MFBS Board Assy (three screws).
4040IXC009DB
Wiring saddle ➁
4551IXC011DA
4040IXC009DB
4040IXC008DB
E-2
8. Reinstall the Upper Right Cover that has been 11. Remove the rear cover of the machine (8
removed in step 4. screws).
4040IXC020DB 4551IXC013DA
9. Connect the connector that has been removed in 12. Install the PWB support to the position shown in
step 3 to the connector (CN7) of the MFBS Board the picture.
and place the Hookup Harness in the one wiring
saddle.
Wiring saddle
CN7
4551IXC014DA
4040IXC021DA 13. Insert the PWB support into the lower left of the
FAXS board and install the FAXS board (3
10. Cut off the knockout cover of the Rear Left screws).
Cover with the appropriate tool such as nipper.
4551IXC015DA
4551IXC012DA
E-3
14. Install the Wiring Saddle (4 places) and the 17. Place the cable in the Wiring Saddle (4 places)
Edge Cover (1 place). and the Edge Cover (1 place).
4551IXC016DA 4551IXC019DB
15. Connect the connector of Cable to the connector 18. Set the battery and fix it with the Tie band.
(CN6) on the MFBS board. 19. Connector the connector of battery to the con-
CN6 nector (CN10) on the BCRS board.
CN10
4551IXC017DA
4551IXC020DB
4551IXC018DA
4551IXC013DA
E-4
21. Reinstall the Upper Rear Cover that has been IV. Setting the Communication Mode
removed in step 2.
1. Since the Communication Mode is set to “E-Mail”,
Note:
it needs to be switched to “G3” as necessary.
When reinstalling the Upper Rear Cover, pass the
2. Set the Communication Mode by following the
angle detecting lever into the hole in the cover.
procedure below.
Angle detecting lever
Utility/Counter → Admin. Management → Enter the
Administrator Code → Admin. 1 → TX Setting →
Quality/Mode → Communication Mode → FAX
4040IXC006DA
4040IXE147DA
4040IXE212DA
E-5